气体检测仪培训教材(ppt)

合集下载
  1. 1、下载文档前请自行甄别文档内容的完整性,平台不提供额外的编辑、内容补充、找答案等附加服务。
  2. 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
  3. 3、如文档侵犯您的权益,请联系客服反馈,我们会尽快为您处理(人工客服工作时间:9:00-18:30)。

78%氮气 20 .9 % 氧气 1.1%的其他气体
水蒸气 二氧化碳 氩气 其他气体
Oxyg氧en气D不ef足iciency
Air is oxygen deficient whenever concentration is less than 19.5% O2 当空气中氧气浓度低于19.5% 时就为氧气缺乏
Atmospheric Monitoring 大气检测
爆炸或易燃的大气环境
Explosion Tetrahedron 爆炸机理
燃烧物
氧气
燃烧源
链反应
Oxygen Enrichment 氧气过量
• Dramatically promotes and accelerates combustion 明显加强和加速燃烧
• Most conservative approach is to use 22 % as take action point 大部分保守观点是含量超过22 %
Lower Explosive Limit (L.E.L.) 爆炸下限
• Minimum concentration of a combustible gas or vapor in air which will ignite if a source of ignition is present 可燃气体或蒸气在空气中引起燃烧的最低 浓度
气体检测仪培训教 材(ppt)
(优选)气体检测仪培训教材
Atmospheric Monitoring 大气检测
Three basic kinds of hazards: 三种基本危险
• Oxygen (deficiency and enrichment)
氧气(缺乏或过量)
• Flammable gases and vapors
• Never use O2 to ventilate a confined space! 禁止使用将氧气直接通过通风进入密闭空间
• Proportionally increases the rate of many chemical reactions 相应地增加化学品反应的速率
• Can cause ordinary combustible materials to become flammable or
5.0% / vol.
– 丙烷
2.2% / vol.
– 戊烷
1.8% / vol.
– 硫化氢
4.3% / vol.
– 一氧化碳
12.5% / vol.
• 完全燃烧环境的气体浓度 (100% LEL) … 和… 爆炸下限传感器 反应的比率不是线性的, 无论如何, 顺序通常是一样的
Flammability Range 燃烧范围
气体浓度
燃烧范围
LEL
UEL
Combustible Gas/vapor Instruments Read in “Percent LEL”
可燃气体/蒸气仪器的读数以百分比指示“LEL”
气体浓度
燃烧范围
0
100% LEL
Combustible Hazard 燃烧危害
Causes of Oxygen Deficiency 造成氧气不足的原因
• Displacement
惰性气体置换
• Microbial action
Βιβλιοθήκη Baidu
生物/细菌行为
• Oxidation
氧化
• Combustion
燃烧
• Absorption
吸收
Oxygen Sensor Detection Principle 氧气检测传感器原理
“Fuel cell” principle 燃料电池原理
• Sensor generates electrical current proportional to the O2 concentration 传感器产生同氧气浓度成比例的电流
• Sensor used up over time (usually last one to two years) 传感器长期使用将会失效(通常持续1到2年)
explosive
可将普通
可燃物变成易燃或可爆炸物
Oxygen Enrichment 氧气过量
• 29 CFR 1910.146 specifies 23.5 % is oxygen enriched 氧气含量超过23.5 %为氧气过量
• Other codes are more stringent 其他法规更严格
易燃气体和蒸汽
• Toxic contaminants
有毒污染物
Atmospheric Monitoring 大气检测
Oxygen Deficiency 氧气缺乏
Atmospheric Monitoring 大气检测
OSHA Has Determined Asphyxiation to Be the Leading Cause of Death in Confined Spaces
Symptoms of Oxygen Deficiency 氧气缺乏的特征
20.9 % 19.5 % - 12 %
12 % - 10 % 10 % - 6 % 6% - 0%
新鲜空气中氧气含量
判断力降低,脉搏和呼吸加快,疲劳,协 调能力降低
呼吸紊乱, 循环降低, 疲劳恶化和失去重要 功能,在几秒钟到几分钟内出现其他症状 恶心, 呕吐, 行动无力, 失去直觉, 直至死亡 抽搐, 呼吸急促, 呼吸停止, 心跳停止, 在数 分钟内出现失去直觉,死亡症状
OSHA法规确定窒息性(惰性)气体是造成 密闭空间死亡的主要原因
Atmospheric Monitoring 大气检测
Composition of fresh air 新鲜空气的组成成分
• 78 % nitrogen • 20.9 % oxygen • 1.1 % all other gases
• Water vapor • CO2 • Argon • Other trace gases
A combustible hazard exists
whenever readings exceed 10% LEL
当爆炸下限超过10%时 就会存在燃烧危险
LEL Concentrations for Different Gases 不同气体的LEL浓度
• 等同于100% LEL的气体浓度:
– 甲烷
相关文档
最新文档