汽机培训教材PPT(共 34张)
合集下载
相关主题
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
The system mainly includes the following main equipment items: HP gland seal steam supply regulating station, LP gland seal steam supply regulating station, HP water spray desuperheating regulating station, LP water spray desuperheating regulating station, various cut-off valves and drain valves, gland seal coolers and drain flask tanks etc. It can exercise a function of maintaining the steam pressure inside the gland seal steam supply mainline between 0.107 Mpa and 0.11 Mpa, the steam temperature between 121℃ and 150 ℃. The control signals can be sent to the control room according to the specific cases and then control the action of various actuators through the DCS system.
the teeth on the seal rings surround the rotor with a clearance being kept to prevent any contact between the said teeth and the rotor surface during the turbine in operation. 在汽轮机启动时，凝汽器抽真空，汽缸内的压力低于大气压力，供至“A”腔室的 汽封蒸汽在一侧通过汽封漏入汽轮机汽缸内，在另一侧漏入“B”腔室，汽封抽汽 器正常运行，使“B”腔室维持压力稍低于大气压力，因而空气通过端汽封漏入“B” 腔室，形成汽气混合物，通过一个与汽封抽汽器相连的接口，从“B”腔室被抽出。 (见图1) During startup of the steam turbine, the condenser is evacuated and the pressure in the cylinders is lower than the atmospheric pressure. The steam supplied to the “A” chamber of the gland seal is leaked to the cylinder of the turbine at one side and to “B” chamber at another side. If the air ejector for the gland seals is in normal operation to maintain the pressure in “B” chamber slightly lower than the atmospheric pressure, the air is leaked into the “B” chamber through the gland seal at the end, forming a steam and air mixture. Then the mixture is evacuated from “B” chamber via a port connected with the air ejector for the gland seals (see Fig.1).
capable of supplying steam to HP and LP cylinder separately developed .
喀北电站汽机资料
系统中主要设备有：高压轴封供汽调节站、低压轴封供汽调节站、高压 喷水减温调节站、低压喷水减温调节站、各种截止阀、疏水阀等，连同 汽封冷却器、疏水扩容器等设备，共同构成了该机组汽封系统。该系统 能够维持汽封供汽母管的压力在0.107～0.11MPa(A)之间，供汽温度在 121～150℃之间，控制部分可根据实际情况接入控制室，通过DCS系统 调节各执行机构动作。
喀北电站汽机资料
Steam seal cooler
辅助蒸汽 母管
喀北电站汽机资料
Steam seal cooler
汽封系统图
喀北电站汽机资料
Steam seal cooler
喀北电站汽机资料
本系统是高低压分开供汽的汽封系统. The present system is a gland seal system
喀北电站汽机资料
转子汽封 Gland Seal of Rotor 在汽缸两端装有汽封体和汽封圈，汽封圈上汽封齿环绕转子，表面仅留有为防止
在运行过程中发生接触的间隙。 Gland casings and sealing rings are equipped at both ends of the cylinder and
Measures must be taken at the portions where the turbine rotor passes through the outer casing to prevent the air leakage from outside into the casing and affect the vacuity of the exhaust hood. In the meantime, the steam inside the casing must also be prevented from its leakage to the outside, especially, to the front bearing box to lead to a mixing of the lubrication oil with water and to the turbine house to deteriorate its environmental conditions. The gland seal system of a steam turbine is furnished just for such a purpose.
喀பைடு நூலகம்电站汽机资料
GLAND SEAL SYSTEM
喀北电站汽机资料
在汽轮机转子穿过外缸的部位，必须采取措施用以防止外部空气 漏入汽缸，从而影响排汽缸的真空，同时也必须防止汽缸内蒸汽 漏出汽缸，漏入前轴承箱容易造成油中带水，漏至汽机房破坏汽 机房环境。汽轮机的汽封系统就是为了完成这一功能而设置的。
the teeth on the seal rings surround the rotor with a clearance being kept to prevent any contact between the said teeth and the rotor surface during the turbine in operation. 在汽轮机启动时，凝汽器抽真空，汽缸内的压力低于大气压力，供至“A”腔室的 汽封蒸汽在一侧通过汽封漏入汽轮机汽缸内，在另一侧漏入“B”腔室，汽封抽汽 器正常运行，使“B”腔室维持压力稍低于大气压力，因而空气通过端汽封漏入“B” 腔室，形成汽气混合物，通过一个与汽封抽汽器相连的接口，从“B”腔室被抽出。 (见图1) During startup of the steam turbine, the condenser is evacuated and the pressure in the cylinders is lower than the atmospheric pressure. The steam supplied to the “A” chamber of the gland seal is leaked to the cylinder of the turbine at one side and to “B” chamber at another side. If the air ejector for the gland seals is in normal operation to maintain the pressure in “B” chamber slightly lower than the atmospheric pressure, the air is leaked into the “B” chamber through the gland seal at the end, forming a steam and air mixture. Then the mixture is evacuated from “B” chamber via a port connected with the air ejector for the gland seals (see Fig.1).
capable of supplying steam to HP and LP cylinder separately developed .
喀北电站汽机资料
系统中主要设备有：高压轴封供汽调节站、低压轴封供汽调节站、高压 喷水减温调节站、低压喷水减温调节站、各种截止阀、疏水阀等，连同 汽封冷却器、疏水扩容器等设备，共同构成了该机组汽封系统。该系统 能够维持汽封供汽母管的压力在0.107～0.11MPa(A)之间，供汽温度在 121～150℃之间，控制部分可根据实际情况接入控制室，通过DCS系统 调节各执行机构动作。
喀北电站汽机资料
Steam seal cooler
辅助蒸汽 母管
喀北电站汽机资料
Steam seal cooler
汽封系统图
喀北电站汽机资料
Steam seal cooler
喀北电站汽机资料
本系统是高低压分开供汽的汽封系统. The present system is a gland seal system
喀北电站汽机资料
转子汽封 Gland Seal of Rotor 在汽缸两端装有汽封体和汽封圈，汽封圈上汽封齿环绕转子，表面仅留有为防止
在运行过程中发生接触的间隙。 Gland casings and sealing rings are equipped at both ends of the cylinder and
Measures must be taken at the portions where the turbine rotor passes through the outer casing to prevent the air leakage from outside into the casing and affect the vacuity of the exhaust hood. In the meantime, the steam inside the casing must also be prevented from its leakage to the outside, especially, to the front bearing box to lead to a mixing of the lubrication oil with water and to the turbine house to deteriorate its environmental conditions. The gland seal system of a steam turbine is furnished just for such a purpose.
喀பைடு நூலகம்电站汽机资料
GLAND SEAL SYSTEM
喀北电站汽机资料
在汽轮机转子穿过外缸的部位，必须采取措施用以防止外部空气 漏入汽缸，从而影响排汽缸的真空，同时也必须防止汽缸内蒸汽 漏出汽缸，漏入前轴承箱容易造成油中带水，漏至汽机房破坏汽 机房环境。汽轮机的汽封系统就是为了完成这一功能而设置的。