响应面法优化莲花总黄酮超声辅助提取工艺及其抗氧化性的研究
合集下载
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
第38卷第5期 2019年9月
浙江海洋大学学报(自然科学版) Journal of Zhejiang Ocean University(Natural Science)
文章编号：2096-4730(2019)05-0436-06
Vol.38 No.5 Sep., 2019
响应面法优化莲花总黄酮超声辅助提取工艺及其 抗氧化性的研究
Abstact： In order to explore the optimum technological conditions for ultrasonic assisted ethanol extrac
tion of total flavonoids from lotus flower and the antioxidant activity of extracts, on the basis of single factor ex periments, the ratio of materials, ethanol volume fraction and extraction time were selected as independent variables, and the extraction rate of flavonoids was the response value. The ox-Benhnken experiment with three factors and three levels was designed to optimize the extraction rate of total flavonoids from lotus flower. The extraction rate was determined by Prussian method. Antioxidant activity. The results showed that the optimum technological conditions for ultrasonic-assisted extraction of total flavonoids from lotus were as follows: material ratio 1:30 (g * mL_1), ethanol volume fraction 70%, extraction time 29 min and extraction times 2 times. Under this condition, the extraction rate of total flavonoids from lotus was 14.07%. It is close to the predicted value of
贺文韬1,林 林2,陈雨涔1,陈 浩3,邓尚贵1
(1.浙江海洋大学食品与医药学院，浙江舟山316022; 2.舟山市农林科学研究院，浙江舟山316000; 3.舟山市普陀农林局，浙江舟花总黄酮的最佳工艺条件及提取液的抗氧化性，在单因素实验的基础上,选取物
收稿日期：2019-02-11 基金项目：舟山市科技局科研项目(2018C13207) 作者简介：贺文韬(1995-),男，浙江舟山人，硕士研究生，研究方向：食品安全与营养.E-mail: yqdzjou@ 通信作者：邓尚贵(1968-),男，博士，教授，研究方向：食品安全与营养.E-mail: dengshanggui@
HE Wen-tao1, LIN Lin2, CHEN Yu-cen1, et al
(1. School of Food Science and Pharmaceutics of Zhejiang Ocean University, Zhoushan 316022; 2. Zhoushan Academy of Agricultural and Forestry Sciences, Zhoushan 316000, China)
相近。此工艺条件下提取的莲花总黄酮其抗氧化性能随浓度升高而增大，低浓度时其抗氧化性比抗氧化剂BHT略弱，高浓
度其氧化性远远大于BHT的抗氧化性。
关键词：莲花；响应面法；总黄酮；微波提取率；抗氧化性
中图分类号：TS207.3
文献标识码：A
Study on the Optimum Extraction Technology and Antioxidant Activity of Total Flavonoids from Lotus
料比、乙醇体积分数、浸提时间为自变量，黄酮提取率为响应值，设计3因素3水平的ox-Benhnken实验对莲花总黄酮的提
取率进行优化，普鲁士兰法测定提取物的抗氧化性。结果表明，超声辅助提取莲花中总黄酮的最佳工艺条件为:物料比1:30
(g-mf1)、乙醇体积分数70%、浸提时间29 min,提取次数2次,此条件下莲花总黄酮提取率最高为14.07%。与预测值13.92%.
第5期
贺文韬等：响应面法优化莲花总黄酮超声辅助提取工艺及其抗氧化性的研究
437
13.92%. Under this condition, the antioxidant activity of total flavonoids extracted from lotus flower increases with the increase of concentration. At low concentration, the antioxidant activity is slightly weaker than that of antioxidant BHT, and at high concentration, the antioxidant activity is far greater than that of BHT.
Key words： lotus; response surface methodology; total flavonoids; microwave extraction rate; antioxidant
浙江海洋大学学报(自然科学版) Journal of Zhejiang Ocean University(Natural Science)
文章编号：2096-4730(2019)05-0436-06
Vol.38 No.5 Sep., 2019
响应面法优化莲花总黄酮超声辅助提取工艺及其 抗氧化性的研究
Abstact： In order to explore the optimum technological conditions for ultrasonic assisted ethanol extrac
tion of total flavonoids from lotus flower and the antioxidant activity of extracts, on the basis of single factor ex periments, the ratio of materials, ethanol volume fraction and extraction time were selected as independent variables, and the extraction rate of flavonoids was the response value. The ox-Benhnken experiment with three factors and three levels was designed to optimize the extraction rate of total flavonoids from lotus flower. The extraction rate was determined by Prussian method. Antioxidant activity. The results showed that the optimum technological conditions for ultrasonic-assisted extraction of total flavonoids from lotus were as follows: material ratio 1:30 (g * mL_1), ethanol volume fraction 70%, extraction time 29 min and extraction times 2 times. Under this condition, the extraction rate of total flavonoids from lotus was 14.07%. It is close to the predicted value of
贺文韬1,林 林2,陈雨涔1,陈 浩3,邓尚贵1
(1.浙江海洋大学食品与医药学院，浙江舟山316022; 2.舟山市农林科学研究院，浙江舟山316000; 3.舟山市普陀农林局，浙江舟花总黄酮的最佳工艺条件及提取液的抗氧化性，在单因素实验的基础上,选取物
收稿日期：2019-02-11 基金项目：舟山市科技局科研项目(2018C13207) 作者简介：贺文韬(1995-),男，浙江舟山人，硕士研究生，研究方向：食品安全与营养.E-mail: yqdzjou@ 通信作者：邓尚贵(1968-),男，博士，教授，研究方向：食品安全与营养.E-mail: dengshanggui@
HE Wen-tao1, LIN Lin2, CHEN Yu-cen1, et al
(1. School of Food Science and Pharmaceutics of Zhejiang Ocean University, Zhoushan 316022; 2. Zhoushan Academy of Agricultural and Forestry Sciences, Zhoushan 316000, China)
相近。此工艺条件下提取的莲花总黄酮其抗氧化性能随浓度升高而增大，低浓度时其抗氧化性比抗氧化剂BHT略弱，高浓
度其氧化性远远大于BHT的抗氧化性。
关键词：莲花；响应面法；总黄酮；微波提取率；抗氧化性
中图分类号：TS207.3
文献标识码：A
Study on the Optimum Extraction Technology and Antioxidant Activity of Total Flavonoids from Lotus
料比、乙醇体积分数、浸提时间为自变量，黄酮提取率为响应值，设计3因素3水平的ox-Benhnken实验对莲花总黄酮的提
取率进行优化，普鲁士兰法测定提取物的抗氧化性。结果表明，超声辅助提取莲花中总黄酮的最佳工艺条件为:物料比1:30
(g-mf1)、乙醇体积分数70%、浸提时间29 min,提取次数2次,此条件下莲花总黄酮提取率最高为14.07%。与预测值13.92%.
第5期
贺文韬等：响应面法优化莲花总黄酮超声辅助提取工艺及其抗氧化性的研究
437
13.92%. Under this condition, the antioxidant activity of total flavonoids extracted from lotus flower increases with the increase of concentration. At low concentration, the antioxidant activity is slightly weaker than that of antioxidant BHT, and at high concentration, the antioxidant activity is far greater than that of BHT.
Key words： lotus; response surface methodology; total flavonoids; microwave extraction rate; antioxidant