涂装专业词汇中英文.

Alkali degreasing 碱液脱脂法
alkali cleaner 碱液脱脂剂
ion exchange 离子交换法
solution control, both control 槽液管理
emulsion edgreasing(cleaner) 乳化脱脂法(剂) chemical decaling ;chemical derusting 化学除锈剂
chemical degreasing 化学脱脂法
chemical conversion coating 化学成膜
rust cause on phosphate coating 黄锈（磷化处理中）chromate coaring, chronating 铬酸处理（钝化）chromate coating chromating 铬酸盐处理
sodium silicate 硅酸钠
descaling 打锈
descaling,derusting 除锈（同酸洗、酸蚀）acid pickling,pickling 酸洗（同除锈）
acid pickling in hibitor 酸性阻蚀剂sankblasting ,blast cleaning 喷砂
deionized water (rinsing) 纯水（洗）
shot blasting 喷丸
fresh water rinsing 新鲜水洗
steam phosphating 蒸气磷化处理
spray pretreatment system 喷射式前处理
total acid 总酸度
accelerator 促进剂
degreasing 脱脂
cleaner 脱脂剂
phosphoric acid cleaning 脱脂，除锈二个合一处理剂
blue color 灰蓝色
vapor degreasing 三氯乙烯脱脂（蒸气）trichloroethylene 三氯乙烯parchlorlerhylene,carbontetrachlchlcride 四氯乙烯
half dip pretreatment system 半浸式前处理
P ratio P比
phosphating chemicals 磷化处理剂chemical conversion coating 皮膜处理
coating weight 膜重
surface treatment 表面预处理
surface conditioning 表面调整
surface conditioner 表面调整剂
flood spray pretreatment system 溢流喷射式前处理full dip pretreatment system 全浸式前处理pretreatment 前处理
pretreament chemicals 前处理剂
drying off 烘干水份
free acid 游离酸度
solvent degreasing 溶剂脱脂
precleaning 预洗净
hot water prerinsing 预热水洗
ziue phosphating phosphatetreatment 锌盐磷化处理
zinc phosphating coating 锌盐磷化膜
iron phosphating coating 铁盐磷化膜
anodic electro deposition 阳极电泳
anode earth method 阳极接地法
spitting spray ,fluttering 气喘、喷流间断
wet on wet 湿碰湿
top coat 涂面漆
air spraying 空气喷涂
air blow 吹风
airless spraying 无空气喷涂
over spray 过喷涂
membrane system electro deposition 隔膜（电极）电泳涂装over coating 重叠涂装
wet sanding with gasoline 汽油打磨
cathodic electro deposition 阴极电泳涂装
dry sanding 干打磨
gun distance 喷枪距离
spray gun velocity 喷枪移动速度mechanical sanding 机械打磨
surface preparation 表面准备（同底材面调整）electrostatic air atomixing spray metode 空气雾化式静电涂装
mill scale 黑皮（黑色氧化皮）finish sanding 修饰性打磨
substrate 底材（基底）
primer coating 涂底漆
dipping,dip coating 浸涂
spraying ,spray coating 喷涂
(atomizing) fan pattern 喷涂影
spot repair 局部修补
three coat three bake 涂三次烘三次
slipper dipping 拖式浸涂
electrostatic coating 静电涂装
electrostatic powder coating 静电粉末涂装electrostatic rotary atomizing spray method 静电雾化式静电涂装法all pattying 统刮腻子
application trial 试涂装
turn-over 更新期
pad application,padding 揩涂
(paint) mixing 调制
color matching 调色
throwing power 泳透力
electro phoresis 电泳
electro osmosis 电渗
electrodeposition,electrocoating (ED) 电泳涂装
sanding,grinding 打磨
painting,coating ,finishing 涂装
interval between coats,coat interval 涂装间隔
paint system ,coating system 涂装体系
paint process 涂装工艺
painting sepctification 涂装技术要求transfer efficiency 涂着效率
color sealer 同色封底涂层surface coating ,sealer coating 涂中涂层repainting 重新涂装spreading rate 涂布面积比
brush application ,brushing,brush coating 刷涂
work 被涂物
atomizing 雾化
detail sanding ,defect sanding 局部打磨
flow coating 淋涂electrophorectic powder coating 粉末电泳涂装法knifing ,knife application 刮涂
touch up 修补涂装
hot spraying ,hot spray coating 热喷涂
masking 遮盖
polishing 抛光
mettalic coating 金属闪光漆涂装utra filtration(UF) 超滤
flridized powder bed coating 流化床涂装application by roller,roller coating 辊涂
(dark)infrared drying ,infrarde drying,infrarde baking （暗）红外干燥wet film 湿涂膜
sand dry ,surface dry 表干
baking,thermosetting 加热干燥
drying 干燥
forced drying 强制干燥
dry-hard,dry-through,hard dry,dry through,baking 完全干燥，完全固化
ultra violer curing 紫外线固化干燥set to touch ,dust free,dry to touch 触指干燥
air drying cold curing 自然干燥（常温干燥）
curing by polymerization 聚合干燥drying by evaporation 蒸发干燥（同挥发干燥）
setting ,flash off 晾干
electoro beem curing ,radiation curing 电子束固化（辐射干燥）
hot air drying couvection drying 热风干燥，对流干燥
tack free ,tack dry 半固化干燥（指触干燥）
baking stoving 烘干
acrylic resin paint 丙烯酸树脂涂料acryl lacquer 热塑性丙烯酸涂料application solid 施工固体份amine content 胺浓度
alkyd resin paint 醇酸树脂涂料cobwebbing 拉丝现象
etching grimer 腐蚀底漆（同磷化底漆，活性底漆）
enamel 磁漆
non aqueous dispersion paint 非水分散型涂料
oil surfacer 油性二道浆
ash content 灰分
cathodic electrod eoposition 阴极电泳涂料flexibility 弹性，可弯曲性nonvolatile content(matter),solids content,heating residue 不挥发分skinning 结皮性
bake schedule 干燥时间
pigment volume,pigment volume concentration 颜料体积比率pigment content 颜料分（P、W、C）
dilution stability 稀释稳定性redueed paint 稀释好的涂料caking 凝结性
coulomb efficiency 库仑效率
clear 清漆
clear lacquer 硝基清漆synthetic resin paint 合成树脂涂料guide coat 二道浆anticorrosive coating ,rust inhibiting paint ,corrosion resistant coating,antirust paint
防锈涂料
primer 底漆涂料chassis black paint 底盘黑涂料zinc rich primer 富锌底漆water borne paint 水性粉笔料（水系涂料）
water soluble resin paint ,water soluble resin coating 水溶性树脂涂料stomeguard coating 抗石击性涂料compatiblity ,compotible 相溶性
spray mist compatibiliity 抗漆雾污染性touch up primer 局部修补底漆thixotropic ,thixotropy 触变性antichippimg paint,chip resistant paint 抗崩裂性
shelf life ,storage stability,canstability 贮藏稳定性
grainning,bitty,seed 细度、粒度
flat paint ,flat oikl paint ,mat paint 无光涂料electrocoating ,coating for electrodeposition 电泳涂料
film forming agent ,film forming ingredient ,
film former,film forming material 涂膜主要成分color surfacer 同色涂料coating ,paint 涂料
virgin paint ,UN-cut paint 原漆
two component paint 双组份涂料nitrocellulose lacquer,nitrocellulose coating 硝基漆thermosetting（themoplastic）acrylic paint 热固(塑)性丙烯酸树脂涂料
consistency 稠度
viscosity 粘度
high solid lacquer 高固体份硝基漆high solid paint 高固体分型涂料binder 基料
putty 腻子
light curing coating 光固化涂料vehicle 漆料phenolic coating ,phenolic resin paint 酚醛树脂涂料unsaturated polyester paint 不饱和聚脂涂料
primer surfacer 底漆二道浆blocking 粘结、结块powder paint 粉末涂料
anti-corrosion wax ,anti-rust wax 防锈蜡
pot life ,pot stability 活化期、活化寿命
polyester putty 聚酯腻子water dispersible paint 水分散型涂料millbase ,milling base 研磨色浆solventless coating ,solvent free paint 无溶剂型涂料
metallic enamel,metallic paint ,metallic pigmented paint 金属闪光色磁漆
thermosetting paint 烘烤型涂料oil paint 油性涂料
oil length 油度
lacquer 硝基清漆lacquer enamel 硝基磁漆bituminous paint 沥青涂料leveling 流平性varnish 清漆
acrylate resins 丙烯酸系树脂acrylic acid 丙烯酸
acryl modified slkyd resin 丙烯酸改性的醇
酸树脂
asphalt (bitumen) 沥青amino resin 氨基树脂alkyd resin 醇酸树脂epoxy resin 环氧树脂
oil free alkyd resin 无油醇酸树脂
external plastici zation 外部增塑化drying oil 干性油hilsonite 天然硬沥青glycerin 甘油
gel time ,time for gelation 胶化时间saponification value ,saponification number 皂化价safflower oil 红花油carbooxyl acid 脂肪酸nitrocellulose 硝化棉
silicone resin 有机硅树脂polybasic acid 多元酸polyhydric alcohol polyol 多元醇
natural resin （oil）天然树脂(油) internal plasticization 内部塑化thermisettig property 热固性thermoplastic ,thermoplasticity,thermal plasticity 热泪盈眶可塑性castor oil 蓖麻油
phenol resin 酚醛树脂nondrying oil 不干性油blown asphalt 氧化沥青ployester 聚醋polybutadience 聚丁二烯methacrylic acid 甲基丙烯酸iodine value ,iodine number 碘值
asbestin 石棉粉aluminium flake powder,aluminium pigment powder 铝粉aluminium flake paste,aluminium pigment paste 铝粉膏
tint(ing) shade,reduce shade 色光、色头
red lead 红丹
carbon black 碳黑
pigment 颜料
oil absorption value 吸油量
clay 白土、陶土
rust preventing pigment, rust inhibiting pigment 防锈颜料extender filler ,extender pigment 填料、体质颜料talc 滑石粉
white tiianium pigment 钛白
color pigment (strength) 着色颜料（力）lead pigment 铅系颜料titanum dioxide 二氧化钛
permanent red 永固红
fast yellow 耐晒黄dispersion 分散
red iron oxide 铁红inorganic pigment 无机颜料organic (color) pigment 有同颜料leafing 漂浮
sellosolves (solvent) 醇醚溶剂alcohols(solvent) 醇系溶剂isopropyl alcohol 异丙醇
ethers(solvent ) 醚系熔剂
esters (solvent) 酯系溶剂
ethyl alochol 乙醇
diluent 稀释剂
xylene 二甲苯
ketones (solvent) 酮系溶剂
high boiling point solvent, high boiler ,slow solvent 高沸点溶剂ethyl acetate 乙酸乙酯aliphatic hydrocarbons (solvent) 脂肪族系碳氢化合物溶剂
cosolvent 助溶剂cellosolve 溶纤剂cellosolve acetate 乙酸溶纤剂solvent naphtha 煤焦油溶剂kerosene ,kerosine 煤油
toluene 甲苯
butyl alcohol ,butanol 丁醇
mineral spirit,petroleum spirit 白醇
methyl ethyl ketone 甲乙酮
amine 胺
surface active agent surfactant 表面活性剂plasticizer 增塑剂
reducidility 稀释剂
metallic soap ,metal soap 金属皂
harder ,curing abent 固化剂
antioxdant ,oxidant inhibitor 防止氧化剂ultrviolet absorber 紫外线吸收剂dibutyl phthalate 苯甲酸二丁酯thinner 稀料
antistatic agent 静电防止剂antisag agent 流挂防止剂antisetlle agent 沉淀防止剂
flatting agent 消光剂
paint thinner 涂料用稀料
lacquer thinner 硝基漆用稀料retarder ,retarder solvent 防潮剂rheology control 流变性控性
paper tack stick 粘性纸胶带
dry sandpaper 干打磨用砂纸crape masking 纸质遮盖用胶带abrasive paper sandpaper 打磨砂纸abrasive colth ,sanding cloth 打磨砂布washing solvent (flame retarding solvent ) 清洗用溶剂water proof abrasion sandpaper 耐水性砂纸heat stabe maskingtape 耐热遮盖用胶带tack rag 粘性纱布tackrag varnish 粘灰清漆
paint remover 脱漆剂polishing compound 抛光剂
poly net 打磨网masking tape 遮盖用胶带hiding power,obiterating power ,covering power ,opacity 遮盖力
top coat,finish coat ,finishing coat 面漆层overcoatability 涂面漆的适应性
recoatability 重复涂装的适应性
glass transition point 玻璃化点specular gloss,specular reflection 镜面光泽度grindability 打磨性pentrability 浸透性distinctness of image 鲜映性alkaliproof ,alkali resistance 耐碱性overbake resistance 耐过烘性
salt water resistance 耐盐水性gasoline resistance 耐挥发油性durability 耐久性flexibility ,elasticity 耐弯曲性weather resistance, weathering property,weatherproof 耐候性acidproof ,acid resistance 耐酸性
impact resisrance 耐冲击性corrosion resistance 耐蚀性
water resistance,waterproof 耐水性washability 耐洗净性chiping resistance 耐崩裂性
heat resistance 耐热性
boiling water resistance 耐沸水性abrasion resistance 耐摩耗性chemical resistance 耐药品性
oil resistance ,oilproof 耐油性
solvent resistance 耐溶剂性
gloss 光泽
flat 无光泽
stain resistance 涂膜污染性
appearance of paint film,paint film appearance 涂膜的外观surface of paint film 涂面
semigloss 半光泽abhesion 附着力
elusion ,bleeding 溶出degradation 裂解
ageing 老化
oildeaetting,oil cratering 油缩孔
water slaining (marke) 雨水痕迹
bubble ,bubbling (bubble trace on ED film) 气泡（电泳气泡）peeling off wet Ed film 电泳湿漆膜脱落ED cratering 电泳缩孔pinpole on ED film 电泳针孔discollration 掉色
off color 色差
mottling 色不均
flooding 色分离
wet contamination 湿污染
pecking 啄伤
gas checking,gas crazing 气体裂纹blushing 白化
pigment sedimentation 颜料沉降sanding scratch 打磨器纹sealing failure 涂密封胶不良bleeding 底层污染stain,spot,spotting 粘污crinkling,shrivelling,wrinkling,rivelling 起皱
suction ,absorption 吸收
water bubbling 水泡
hiding failure 遮盖不良scrack 划伤
low distinctness of image 鲜映性低intercoat adhesion failure 层间剥落fading 退色dripping 流痕sagging run curtaining 下沉
sag 流挂
wrinkle 皱纹起皱chipping 碎落chalking 粉化
thin Edcoating ,no ED coating 泳透性差dulling,loss of gloss,matting 失光flashing 光泽不匀sand scratch 打磨划伤
too much film thickness 涂膜过厚peeling 涂膜剥落
dry contamination 干污染
dirt ,seed 涂料颗粒cratering,fish eye 涂料缩孔，鱼眼
sagging,runing 流淌
bleeding 渗色
thin paint 涂得太薄skips 漏涂
peeling 剥离crawling,fish eye,cratering 缩孔鱼眼
ding and dent 钣金凹凸soldering pinhole 焊药针孔pinhole 针孔blistering 膨泡
bunp,cluster 颗粒
blushing 发白
blistering 起泡
mar 触伤痕
hair cracking 鬓状裂纹sanding scratch 砂纸纹cratering 凹坑discorloration 变色
swelling 膨润
shading 模糊（阴影）comet star pineple 星状不平break line failure 保护不良metallic seeding 金属颗粒after tack 返粘
under baking 未烘干透grinding scratch 锉刀纹orange peel 桔皮solvent popping ,pin holes 气泡孔cracking,hair craching,checking ,craging,alligateying crocodiling
裂纹鬓状裂纹浅裂纹龟裂鳄鱼皮裂纹
filiform corrosion test 丝状腐蚀性试验hiding chart 遮盖力试验纸wet film thickness gauge 湿漆膜厚度量远规
Erichsen film distensibility meter 杯突试验机Elcometer 永久磁性测厚仪salt spray testing ,salt spray test 盐水喷雾试验pencil hardness test 铅硬度试验carbon arc 碳弧灯appearance inspection 外观检查dilution stability test 稀释稳定性试验dilytion test,reducibility test 稀释试验xenone lamp 氙气灯
coulomb efficiency test 库仑效率试验bending test 弯曲试验gravelometer 石击崩裂试验法cryptoneter 遮盖力测验法Krebs -Stomer viscometer,Stomer viscometer 斯端马粘度计cross cut 交叉横割constant temperature and humidity cabinet 恒温恒湿箱gloss meter 光泽计
color difference meter 色差计
test panel 试验板
test piece,coupon,specimen 试验样板outdoor wethering test ,outdoor exposure test 自然曝晒试验imact test,impact testing ,chip test 冲击试验impact tester 冲击试验仪sampler 取样器Sward hardness rocker 斯惠特硬度计scab corrosion test 疤形腐蚀试验accelerated weathering test,accelerated weathering ,artificial weathering 人工耐候性试验
accelerated weathering tester 人工耐候性试验机
over bake resistance test 耐过烘性试验
hot water resistance test 耐温水试验
weathering test ,weathering 耐候性试验
humidity resistance test 耐湿试验
humidity box 耐湿试验盒
chemical resistance test 耐药品性试验
diamond shot test 金刚石冲击试验法
throwing power 泳透性试验
grind gauge ,fineness gauge 细度刮板Du-pot impact tester 杜邦式冲击试验
heat cycle test 热循环试验
exposure rack 曝晒试验Broodfield viscometer B型粘度计
portable distinctness of image glossmeter 鲜映测计（PGD）
specific gravity cup 比重杯specified achromatic light 标准光源film applicator 涂膜涂布器
Ford cup ,Ford viscosity cup 福特杯compound corrosion test 复合腐蚀试验（CCT）
tack free test ,print test 不粘性试验film thickness gauge 漆膜厚度计
pressure feed type spray gun 压送式喷枪pressurw tank ,pressure feed paint container 油漆增压箱
rubber patten 子橡胶磨块
patten 木质磨块colors changer 换色装置
water curtain 水幕
air cap 空气帽
air cleaner 空气静化器
air compressor 空气压缩机
air sander 气动打磨机
air duster 气动除尘器
air transformer 空气压力调整器
airless spray gun 无气喷枪airless apraying equipment 无气喷涂装置auto roll filter 自动滚筒式过滤器
auto absorber 自动吸水器orbital sander 眼眶形打磨机pressure cup 加压杯
rotary air sander 转动型气动打磨机
reverser clean 转动式清洁器stirring equipment 搅拌装置rotary atomizing electrostatic spraying equipment 旋杯式静电喷涂装置
steel spatrla 钢刮刀heating oil separater 加热油水分离装置
dryspray booth 干式喷漆室wood spatula 木刮勺supply duct 供气风管supplying fan 供气风机air supply house 空调装置high voltage regulator 高压发生器
surge chamber 缓冲容器
side room 侧调漆间robot by C.Pteaching method CP式机械手
automatic air duster 自动吹风装置
automatic solution machine 自动溶液管理装置
automatic sanding machine 自动湿打磨装置
automatic washing machine 自动水洗装置
automatic apray machine 自动喷涂机
automatic electrostatic spray machine 自动静电涂装装置
automatic dust off machine 自动除尘装置
automatic spray 自动涂装装置
bravity spray gun 重力式喷枪
deionized water generator 纯水装置pad 托盘（板）dipping tank 浸槽
water washing spray booth 水洗式喷漆室
scraper 刀
spray gun 喷枪spray system pretreatment equipment 喷射式前处理装置
spray booth 喷漆室electrostatic coating equipment 静电涂装装置
electrostatic powder coating equipment 静电粉末涂装装置
semifolw sealing 半浮动涂密封胶
side reciprocator 侧喷机duct 风筒（管）touching tracer 修整追踪装置
double action sander 双动打磨机
DC power equipment 直流电源disc sander 盘式打磨机
hand electrostatic spray gun 手提式静
电喷枪
hand electrostatic spray equipment 手提式静电喷涂装置ceiling filter 顶棚过滤器
electrocoating equipment 电泳涂装装置
painting robot 涂装机械手
cup of spray gun 涂料杯paint circulating system 涂料循环输漆系统
mixing room 调漆室spray gum tip 涂料喷嘴
needle 针阀exhaust air washing system 排气洗净装置
brush 刷子robot by P.T.P.teaching method PTP式机械手
full dip pretreatment system equipment 全浸式前处理装置
top reciprocator 平面涂装机
knife,spatula 刮刀ultra filtration equipment 超滤装置（UF）
light projector 光投影器
robot by remoto teaching method 远距离式教式机械手
continuous settling equipment 连续沉淀装置
dark(far) infrared oven 暗（远）红外线烘干室
air seal 风幕
oven 炉干燥机indirect hot air oven 间接加热式热风烘干室
drying oven 干燥室infrared oven 红外线干燥室enthalpy heat exchanger 全热泪盈眶交换器
hot air converction oven 对流炉direct hot airoven ] 直接加热式热风烘干炉hot air oven 热风炉
hot air circulating equipment 热风循环装置
burner house 燃烧室
heat pump 热泵
radiation panel heater 辐射板
setting room 晾干室
baking oven 烘干室cooling unit 强冷室
color specification 色的规格colorrendition 演色
color chart 色卡
cool color 冷色saturation ,chroma 彩色度（鲜艳度、饱和度或纯度）
brightness 亮度
shade 修色
color difference 色差
color scheme 色彩设计
hue 色相metamerism 条件等色solid color 本色master color 造型色板warm color 暖色
tinting 调色
tint 着色
tone analysis 色调分类color standard (panel) 标准颜色板
flip-flop 闪光spectrophotometer 分光光度计spectral reflection faetor 分光反射率relative spectral distribution 分光分布achromatic color 无彩色value of lightness 明度metallic color 金属闪光色chromatic color 有彩色ionomer resin 离子树脂acrylic resin 丙烯酸树脂acrylonitrile butadiene styrene frepolymer resin 丙烯腈，丁二烯苯乙烯树脂（ABS）
urethane resin 聚氨酯树脂fiberglass reinforced plastics 玻璃纤维增强树脂（FRP）
polyvinyl chloride resin 聚氯乙烯树脂（PVC）vigid polypropylene resin 硬质聚丙烯树脂（硬PP）
hotrolled steel sheet 热轧钢板
polyamide resin 聚酰氨树脂（PA）polystyrene resin 聚苯乙烯树脂（PS）zinc fusing glavanized steel sheet 热镀锌钢板
zinc alloy fusing galvanized steel sheet 热熔合金化镀锌钢板high tensile coldrolled steel sheet 冷轧高强度钢板（SAPH）coldrolled steel sheet 冷轧普通碳素结构钢板（SPCCR）。