三聚氰胺MSDS

Name: Melamine Material Safety Data SheetSynonym: 2,4,6-Triamino-S-Triazine; Aero; Cyanuramide; Cyanurotriamide; Cyanurotriamine; CymeCAS: 108-78-1Section 1 - Chemical ProductMSDS Name: MelamineSynonym: 2,4,6-Triamino-S-Triazine; Aero; Cyanuramide; Cyanurotriamide; Cyanurotriamine; CymelSection 2 - COMPOSITION, INFORMATION ON INGREDIENTSCAS# Chemical Name content EINECS#108-78-1 Melamine 99% 203-615-4Hazard Symbols: XIRisk Phrases: 36/37/38Section 3 - HAZARDS IDENTIFICATIONEMERGENCY OVERVIEWIrritating to eyes, respiratory system and skin.Potential Health EffectsEye:Causes eye irritation.Skin:Prolonged and/or repeated contact may cause irritation and/or dermatitis. Ingestion:May cause gastrointestinal irritation with nausea, vomiting and diarrhea. Inhalation:May cause irritation of the respiratory tract with burning pain in the nose and throat, coughing, wheezing, shortness of breath and pulmonary edema. Chronic:May cause cancer according to animal studies. May cause reproductive and fetal effects.Section 4 - FIRST AID MEASURESEyes: Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Skin:Immediately flush skin with plenty of soap and water for at least 15 minutes while removing contaminated clothing and shoes. Get medical aid if irritation develops or persists. Wash clothing before reuse.Ingestion:Do NOT induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.Inhalation:Remove from exposure to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.Get medical aid.Notes to Physician:Section 5 - FIRE FIGHTING MEASURESGeneral Information:As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas.Extinguishing Media:Use water spray, dry chemical, carbon dioxide, or chemical foam. Use agent most appropriate to extinguish fire.Section 6 - ACCIDENTAL RELEASE MEASURESGeneral Information: Use proper personal protective equipment as indicated in Section 8.Spills/Leaks:Wash area with soap and water. Clean up spills immediately, observing precautions in the Protective Equipment section. Sweep up, then place into a suitable container for disposal. Avoid generating dusty conditions. Provide ventilation.Section 7 - HANDLING and STORAGEHandling:Wash thoroughly after handling. Use with adequate ventilation. Avoid contact with eyes, skin, and clothing. Keep container tightly closed.Avoid ingestion and inhalation. Wash clothing before reuse.Storage:Store in a cool, dry place. Keep container closed when not in use.Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTIONEngineering Controls:Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.Skin:Wear appropriate gloves to prevent skin exposure.Clothing:Wear appropriate protective clothing to prevent skin exposure. Respirators:Follow the OSHA respirator regulations found in 29CFR 1910.134 or European Standard EN 149. Always use a NIOSH or European Standard EN 149 approved respirator when necessary.Section 9 - PHYSICAL AND CHEMICAL PROPERTIESPhysical State: SolidAppearance: whiteOdor: None reported.pH: Not available.Vapor Pressure: 50 mm Hg @ 315 CViscosity: Not available.Boiling Point: sublimesFreezing/Melting Point: < 250 deg CAutoignition Temperature: Not available.Flash Point: Not available.Explosion Limits, lower: Not available.Explosion Limits, upper: Not available.Decomposition Temperature:Solubility in water: Slightly soluble in water.Specific Gravity/Density: 1.573 @ 250CMolecular Formula: C3H6N6Molecular Weight: 126.0822Section 10 - STABILITY AND REACTIVITYChemical Stability:Stable under normal temperatures and pressures.Conditions to Avoid:Incompatible materials, dust generation, excess heat, strong oxidants. Incompatibilities with Other Materials:Strong oxidizing agents; strong acids.Hazardous Decomposition Products:Nitrogen oxides, carbon monoxide, irritating and toxic fumes and gases, carbon dioxide, cyanide fumes.Hazardous Polymerization: Has not been reported.Section 11 - TOXICOLOGICAL INFORMATIONRTECS#:CAS# 108-78-1: OS0700000 LD50/LC50:CAS# 108-78-1: Draize test, rabbit, eye: 500 mg/24H Mild; Inhalation, rat: LC50 = 3248 mg/m3; Oral, mouse: LD50 = 3296 mg/kg; Oral, rat: LD50 = 3161 mg/kg; Skin, rabbit: LD50 = >1 gm/kg.Carcinogenicity:Melamine - IARC: Group 3 carcinogen See actual entry in RTECS for complete information.Section 12 - ECOLOGICAL INFORMATIONSection 13 - DISPOSAL CONSIDERATIONSProducts which are considered hazardous for supply are classified as Special Waste and the disposal of such chemicals is covered by regulations which may vary according to location. Contact a specialist disposal company or the local waste regulator for advice. Empty containers must be decontaminated before returning for recycling.Section 14 - TRANSPORT INFORMATIONIATANo information available.IMONo information available.RID/ADRNo information available.Section 15 - REGULATORY INFORMATIONEuropean/International RegulationsEuropean Labeling in Accordance with EC DirectivesHazard Symbols: XIRisk Phrases:R 36/37/38 Irritating to eyes, respiratory systemand skin.Safety Phrases:S 36/37/39 Wear suitable protective clothing, glovesand eye/face protection.WGK (Water Danger/Protection)CAS# 108-78-1: 1United Kingdom Occupational Exposure LimitsCanadaCAS# 108-78-1 is listed on Canada's DSL List.CAS# 108-78-1 is listed on Canada's Ingredient Disclosure List. Exposure LimitsUS FEDERALTSCACAS# 108-78-1 is listed on the TSCA inventory.。