轮机英语 lesson 16
EnglishofMarineEngineering（轮机英语）
EnglishofMarineEngineering（轮机英语）English of Marine Engineering（轮机英语）Unit 1 ：Main Propulsion Plant（船舶主推进装置）一、船舶动力装置概述●船舶动力装置的组成和类型、热机的类型和应用二、船舶柴油机1)船舶柴油机基本参数、特性指标2)船舶柴油机的工作原理3)船舶柴油机的基本结构4)船舶柴油机的燃油系统5)船舶柴油机的润滑系统6)柴油机的冷却系统7)柴油机的启动系统8)船舶柴油机操纵和控制系统、柴油机的运行管理、故障诊断三、船舶推进装置●推进装置的传动方式Unit 2 ：Auxiliary Machinery（船舶辅助机械）一、船用锅炉1)船用锅炉的类型和结构特点2)船用锅炉的运行管理、故障分析和排除二、船用泵1)船用泵类型；常见船用泵的工作原理和结构特点；船舶通用泵系的布置原则和特点2)常见船用泵的运行管理和故障排除三、船舶制冷和空调装置1)船舶制冷原理和制冷循环2)船舶空调系统的组成及主要设备；船舶空调装置的运行管理、故障分析和排除四、船舶防污染设备1)油水分离器的工作原理及运行管理2)焚烧炉的工作原理及运行管理3)生活污水处理装置的工作原理及运行管理五、分油机和海水淡化装置1)分油机的工作原理及运行管理2)海水淡化原理、主要设备和运行管理六、船舶甲板机械1)起货机的结构特点及其故障分析和排除2)锚机、绞缆机的结构特点及其故障分析和排除3)液压泵、控制阀件和油马达的结构特点；液压系统管理Unit 3：Marine Electrization and Automatization（船舶电气和自动化）一、船用发电机1)船用发电机的结构特点2)船用发电机的并车和解列3)船用发电机的故障分析和排除二、船用配电板1)主配电板的分类及组成2)应急配电板；配电箱三、船舶电气设备●船舶电气设备：船舶电气设备概况；电气控制设备；电气设备运行管理Unit 4 ：Marine Engineering Management（船舶轮机管理）一、操作规程●备车；巡回检查；完车二、安全管理知识1)船舶防火防爆的措施及守则2)轮机部操作安全注意事项；安全知识；机舱应急设备的使用及管理三、油、物料和备件的管理●燃油的管理四、船舶修理和检验1)修理的类别；轮机坞修工程2)船舶检验的类别与作用五、防污染管理及PSC检查1)《油类记录簿》与IOPP证书的管理2)PSC检查中的明显理由与更详细检查；PSC检查报告和缺陷的纠正Unit 5 ：International Convention and Regulations（国际公约与规则）一、STCW公约1)STCW78/95公约中有关轮机值班的基本原则2)轮机员的基本职责和道德；机架联系制度二、MARPOL公约●MARPOL73/78公约中有关含油污水的排放规则；有关国家、港口的防污染规则三、SOLAS公约●SOLAS公约的基本精神和基本原则四、ISM、ISPS等规则和公约1)ISM规则简介2)ISPS规则简介3)其他最新公约和规则。
轮机英语词汇(辅机)
Boiler generating tube：产汽管waste heat boiler：废热锅炉fin：翅片，带翅片heat transfer：传热bottom blow valve：下排污阀blowing down：下排污burner：燃烧器secure the burner：切断燃烧器recover：回收feedwater：给水furnace：炉膛donkey boiler：辅锅炉steam drum：汽锅筒，汽包water drum：水锅筒natural convection：自然对流forced convection：强制对流sinuous fire tube：弯曲的火管PH reading：PH值PH value：PH值caustic soda：氢氧化钠chloride：氯化物，氯含量go out：（火）熄灭，熄火purge：驱气，扫气hydrostatic test：水压测验vent valve：放气阀dissolved solid：溶解的固体settled solid：沉淀的固体calcium sulfate：硫酸钙embrittlement：苛性脆化caustic cracking：苛性脆化oxygen corrosion：氧腐蚀sodium sulfate：亚硫酸钠hydrazine：联氨blinded：封死，堵死secure the fire：熄火extinguish the fire：熄火water level indicator：水位指示器gauge glass：水位计，水位表discrepancy：偏差，不一致impurity：杂质scum valve：上排污阀motor ship：内燃机船soot blower：吹灰器brilliant white flame：亮白色火焰dazzling white flame：亮白色火焰golden yellow flame：金黄色W.H.R. (Waste Heat Recovery)：废热回收shrinkage：缩水air/fuel ratio：风油比attemperator：调温器，温度控制器economizer：经济器surveyor：验船师foam：泡沫，起泡沫alkali：碱性物质flame safeguard control system：火焰保护装置steam demand：蒸汽需求量heating coil：加热盘管flame scanner：火焰探测器sputter：发出劈啪声burned out：烧坏的solenoid：电磁阀distorted：变形的modulate：调节lifting pressure：启阀压力，开启压力steam stop valve：停汽阀shallow dish：浅盘forced draught fan：强力通风机refractory：耐火材料Pumpsreciprocating pump：往复泵gear pump：齿轮泵centrifugal pump：离心泵vane pump：叶片泵positive displacement pump：容积式泵rotor：转子stator：静子mono screw pump=single screw pump：单螺杆泵triple screw pump：三螺杆泵pressure head：压头meter fluid column=mH2O：米液柱impeller：叶轮volute：蜗壳kinetic energy：动能self-priming：自吸的，干吸的rotary pump：回转泵helical gear pump：斜齿齿轮泵cavitation：汽蚀，气穴diffuser pump：导轮式泵plunger pump：柱塞泵be directly proportional to：与….成正比air chamber：空气室continuous：持续的，连续的internal valve：内部阀件interconnected：互通的non-pulsating：无脉冲的stationary ring：静环rotational ring：动环negative suction head：负压头vapor pocket：气泡casing：壳，壳体single stage：单级的multistage：多级的static suction lift：静吸入压头sensible heat：显热eductor pump：喷射泵ejector pump：喷射泵power end：功率端fluid end：流体端bent：弯曲的suction-force principle：吸-排原理erosion：剥蚀potential energy：势能（压力能）vaporizer：蒸发scoring：划痕with regards to：关于Marine refrigeration evaporating pressure：蒸发压力defrost：除霜evaporator：蒸发器refrigerant：制冷剂refrigerating agent：制冷剂state：状态latent heat：潜热dissipate：释放，消散saturation temperature：饱和温度hermetic compressor：封闭式压缩机thermal expansion valve：热力膨胀阀thermostatic expansion valve：热力膨胀阀super-cooled：过冷的sub-cooling：过冷的，过冷superheat：过热度Freon system：氟利昂制冷系统thermal bulb：温包drier：干燥器dehydrator cartridge：干燥器，除湿器extract heat：吸收热量overcharge：充注过多freezing temperature：冰点温度latent heat of fusion：熔化潜热ammonia：氨toxic：有毒的phosgene gas：光气open flame：明火odorless：无味的，没有气味的vessel：船，容器range：范围differential：差值cutout switch：断路器开关react：做出反应CFC refrigerant：不含氢的氯氟烃制冷剂hydrofluoric acid：氢氟酸zinc plate：锌块re-evaporator：再蒸发器，回热器faulty：故障的，有问题的present：提出，现在的，出席的presence：存在diaphragm：膜片ruptured：破裂的be blocked with：堵塞shutter：格栅symptom：征兆halide torch：卤素检漏灯stabilize：使….稳定adjust：调节sensing line：感应管路short cycling：短循环gas mask：气体面罩face shield：面罩cubic foot：立方英尺breathing apparatus：呼吸器flooding back：回液，（压缩机的）液击cryogenic liquid：低温液体brittle fracture：冷脆sight glass：示液镜liquid indicator sight glass：示液镜liquid sight flow indicator：示液镜bubble：气泡sweating：冒汗，有水珠lack of：缺少，不足shortage of：缺少，不足fuse：熔断丝blown：熔化的sensing bulb：感温包release：释放pure refrigerant：纯净的制冷剂troubleshooting：故障排除flash gas：闪气fitting：接头upstream：上游unloader head：卸载缸头sterile mineral oil：无菌矿物油ground joint：研磨接头king valve：主阀trap：捕集器silicon sealant：密封硅胶Air conditioning system simultaneously：同时地，同步地medical help：医疗救助artificial respiration：人工呼吸thermostat：温度控制器balance：使…平衡damper：风门trial and error：反复实验法dehumidifier：除湿器dehumidification：除湿humidification：加湿total heat：总热量saturated：饱和的infiltration：渗透热dew point：露点relative humidity：相对湿度chilled water：冷水re-heater：再热器hermetically sealed：密封式的non-condensable：不凝性的，不凝结的cargo hold：货舱single duct system：单风管系统self-contained air conditioning：独立式空调装置tropical：热带的psychrometer：湿度计Bilge water treatment systemoil collecting space：集油室flooding：进水mud box：泥箱bilge injection valve：舱底吸入阀coalescence：聚合remaining：剩余的，剩下的exceed：超过PPM（parts per million）：百万分之…catch plate：捕集板oil water monitor：油分检测器oil in water monitor：油分检测器slop：污水slop tank:污水舱bilge well：污水井shore side reception facility：岸上接收设备globule：油滴agitate：搅拌liquid level detector：液位探测器back flush：反向冲洗sensor：传感器air cushion：气垫holding tank：集污柜emulsified oil：乳化油oil emulsion：乳化油criteria：标准cross-flow membrane：横流膜片solvent：溶剂flocculent：絮凝剂adsorbent：吸附剂garbage management and biological sewagetreatmentgarbage：垃圾disposal：处理off loading：卸载，排放official number：登记号victual waste：食品废弃物disinfection：消毒disinfection agent：消毒剂disinfector：消毒剂anaerobic bacteria：厌氧菌aerobic bacteria：好氧菌aerobic：好氧的extended aeration process：充分曝气过程oil sludge：油渣maceration：粉碎，浸渍solid waste：固体垃圾，固体废弃物dump chute：投料门digest：消化吸收galley waste：厨房垃圾ash：灰，灰烬rotary nozzle incinerator：旋嘴式焚烧炉oxidation pool：氧化池hypo-calcium chloride：氯化钙innocuous sludge：无害沉渣activated sludge：活性污泥inert sludge：惰性污泥comminuted：粉碎的ground：研磨的stringent：严格的oxidizing：氧化oxygenating：充氧BOD（Biochemical Oxygen Demand）：生化需氧量Oil treatmentpurify：净化interface：分界面back pressure：背压throughput：流量gravity disc（disk）：比重环bowel：分离筒periphery：四周，周围sediment：沉淀物principle：原理，原则principal：主要的ejection process：排渣过程flushing water：冲洗水clarifier：分杂机purifier：分水机locking （lock）ring：锁环clockwise：顺时针的counter clockwise：逆时针的emulsification：乳化batch：分批进行L.O. purifier：滑油分油机percentage：百分比laboratory：实验的，实验室的water damp ring：阻水环，比重环name plate：铭牌optimal ['ɔptiməl] adj. 最理想的；最佳的Marine Desalination Plants desalination: 除盐，淡化evaporate：蒸发condense：冷凝condenser：冷凝器chemical compound：化学剂pure：纯净的alkaline：碱性的feedwater：给水feed box：给水箱，海水箱distil：蒸馏distillate pump：凝水泵at present：目前saturation temperature：饱和温度fresh water generator：造水机vacuum boiling evaporator：真空沸腾式造水机vacuum chamber：真空室vacuum drag：真空塞conductivity：导电性process：过程brine：盐水，海水steam trap：阻汽器portable water：饮用水portable water tank：日用水柜hygienic：卫生的hygienic quality：卫生质量air ejector：空气喷射器eductor：喷射器evacuate：排出，疏散，撤离soft scale：软水垢salinity indicator：盐度指示仪TDS（total dissolved solids）：总溶解固体量demister：汽水分离器Hydraulic system and equipment rotary motion：回转运动linear motion：直线运动rotor：转子proportional to：成比例的，相称的retraction：缩进，回缩contract：收缩direct：指导，指向，引导…的方向direction control valve：方向控制阀（pressure）reducing valve：减压阀check valve：单向阀pressure relief valve：溢流阀unloading valve：卸载阀neutral：中立的，中性的neutral position：中间位置，中央位置gum：胶质varnish：清漆radial piston pump：径向柱塞泵axial piston pump：轴向柱塞泵floating ring：浮环obstructed：堵塞的tilting box：倾斜盘swash plate：倾斜盘dissipate：散发foreign matter：杂质trap：使…受限actuate：开动，驱动，使…作用actuator：执行器，调节器electromagnet：电磁铁sluggish：迟钝的，迟缓的response：反应temporary：临时的electrical power loss：断电flexible hose：挠性软管butterfly valve：蝶阀globe valve：球阀gate valve：闸阀resistance：阻力twist：扭曲slack：松弛moisture separator：水分分离器sample：取样mooring winch：绞缆机instruction book：说明书blockage：堵塞down stream：下游variable displacement system：变量系统constant volume system：定容积系统valve chest：阀箱diaphragm：膜片pre-tensioned spring：预紧的弹簧pilot valve：导阀quick closing valve：速闭阀basket strainer：筒状滤器cartridge：芯件accumulator：蓄压器，蓄能器bleed off：放掉potential energy：势能base：基座power unit：动力装置shock：冲击fitting：配件hammering：锤击声popping：爆裂声sputtering：劈啪声shaft seal：轴封purge air：驱气orifice：小孔thin：稀的，薄的，瘦的thick：稠的，厚的Cargo Handling Equipment crane: 回转式起货机，克令吊brake：制动装置fail-safe：故障安全保护jib：吊臂luffing：变幅（调节吊臂高度）slewing：回转（旋转克令吊）hoisting：提升（装卸货物）pedestal：平台platform：平台visibility：视野，能见度operator：操作者union purchase derrick：吊杆式起货机derrick：吊杆quayside：码头hold：保持，货舱safe working load：安全工作负荷topping wire：顶牵索stay：稳索fore and aft：前后haul in：收进let out：放出（winch）barrel：绞缆筒warp end：卷缆端medium：介质cargo winch：起货机Anchor Windlass and Mooring Winch anchor: 锚split windlass：分离式锚机windlass：锚机chain：锚链cable：锚链cable lifter：锚链轮cable stopper：锚链止链器wildcat：锚链轮spurling pipe：锚链管capstan：锚绞盘engage：啮合rope：缆绳wire：钢缆mooring winch：绞缆机constant-tensioning mooring winch：恒张力绞缆机pier：码头draft：吃水breaking strength：断裂强度mooring line：缆绳reservoir：容器，油箱dog clutch：牙嵌离合器clutch band：离合器带Steering Gearhand steering：手动舵rudder：舵rudder stock：舵柱steering wheel：舵轮telemotor：液压遥控伺服器（远距离操舵伺服器）ram：撞杆cylindrical barrel：圆柱形缸体odd：奇数的even：偶数的log：记录tiller：舵柄cut-off lever：反馈杆floating lever：浮动杆tiller arm：舵柄臂control spindle：控制手柄slipper ring：滑环transmitter：发送器rudder angle：舵角helm：舵轮helmsman：舵工floating ring：浮环eccentricity：偏心距follow-up gear：追随机构error trial：偏差信号torque：扭矩knot：节，海里/小时receiver：接收器。
【知识】船舶轮机英语：基础词汇
【知识】船舶轮机英语：基础词汇第六部分：基础词汇Ⅰ.技术术语 Technical Terms1、pump 泵①Supply pump供给泵②transfer pump 输送泵③circulating pump 循环泵④bilge pump 舱底水泵⑤ballast pump 压载水泵1、tank①drain tank 泄放柜②service tank 日用柜③settling tank沉淀柜④storage tank 储存柜⑤circulating tank 循环柜⑥used oil tank 废油柜⑦buffer tank 缓冲柜⑧overflow tank 溢流柜⑨Collecting tank 收集柜⑩expansion water tank 膨胀水箱2、water①sea water (S.W.) 海水②fresh water (F.W.) 淡水③operating water 工作水④sanitary water 卫生水⑤washing water 冲洗水⑥refilling water 再注水⑦feed water 给水⑧condensate water 冷凝水⑨bilge water 舱底水⑩sewage 污水2、oil①fuel oil (F.O.) 燃油②lubricating oil (L.O.) 滑油③engine oil 机油④cylinder oi l 气缸油⑤diesel oil (D.O.) 柴油⑥turbine oil 透平油⑦cool oil 冷却油⑧seal oil 密封油3、temperature (temp) 温度4、flow 流量5、pressure（press）压力6、power 功率10、level 液位11、vibration 振动12、normal/abnormal 正常/异常13、main/auxiliary (aux.) 主要/辅助的14、inlet/exhaust 进气/排气15、fire alarm 火警16、fail/failure 故障17、overload 过载18、no-voltage 失电19、leak/leakage 泄漏20、wrong-way 错向21、insulation(insul) 绝缘22、oil mist 油雾23、viscosity 粘度24、density 浓度25、salinity 盐度26、oil content 油含量27、pressure difference 压差28、switch 开关29、flame 火焰30、automatic（auto）自动的31、emergency 应急的32、standby 备用的33、screw 螺丝34、nut 螺母35、stud 螺柱36、meter 仪表37、thermometer温度计38、level gauge 液位计38、pressure gauge 压力表39、length 长度40、breadth 宽度41、height 高度42、meter 米43、centimeter 厘米44、millimeter毫米45、decimillimetre 丝米46、micrometer微米46、hundredth of one millimeter 丝47、de(rust)生锈（除绣）48、spare parts 备件49、spanner 扳手50、ahead/astern 正车/倒车51、screwdriver 螺丝刀（minus / plus）52、sludge 油渣53、electrician’s knife 电工刀54、decrustation pliers 剥线钳Ⅱ.（主机主要部件） Main Parts for M/E1、engine frame 机架2、cylinder 气缸3、piston 活塞4、crosshead 十字头5、bedplate 机座6、crankshaft 曲轴7、cylinder cover/head 气缸盖8、connecting rod 连杆9、turbocharger 增压器10、driving chain 传动链11、air cooler 空气冷却器12、scanvage box 扫气箱13、oil sprayer 喷油器14、oil nozzle 喷油嘴15、exhaust valve 排气阀16、sealing ring密封环17、cylinder liner 气缸套18、piston rod 活塞杆Ⅲ.机舱布置图 Engine room arrangement1、main engine /M.E. 主机2、intermediate shaft 中间轴3、bearing 轴承4、propeller shaft 螺旋桨轴5、stern tube艉管6、aft seal head tank 后密封油箱7、FWD seal head tank前密封油箱8、stern tube L.O. drain tank 艉管滑油泄放柜9、chemical cleaning tank 化学清洗柜10、L.O. drain tank11、sludge oil trap 油渣收集柜12、rust preventer tank 防锈剂柜13、 oily water separator油水分离器14、Low sea chest 低位海水门15、L.O. transfer pump16、bilge pump 舱底泵17、M/E lub oil pump18、M/E S.W. cooling pump 主机海水泵19、sludge pump 油渣泵20、ejector pump for F.W.G 造水装置工作水泵21、stern tube L.O. pump 艉轴管滑油泵22、H.F.O. Transfer pump 燃油输送泵23、ballast pump 压载泵24、bilge & G.S. pump 舱底总用泵25、Fire & G.S. pump 消防总用泵26、Provision Ref. Unit S.W. pump伙食冷藏海水泵27、aux. S.W. Cooling pump 辅海水泵28、L.O. purify cleaning tray 滑油分油机洗池29、L.O. purify. Operating water tank 滑油分油机工作水箱30、L.O. purify. Heater滑油分油机加热器31、diesel generator 柴油发电机组32、D/G F.W. Cooler 柴油发电机淡水冷却器33、boiler feed water pump 锅炉给水泵34、cascade tank 热井35、aux.condenser 大气冷凝器36、inspection tank 凝水检查柜37、filter 过滤器38、distilling plant 造水装置39、control air vessel 控制空气瓶40、control air dryer控制空气干燥器41、air compressor 空压机42、main air vessel 主空气瓶43、M/E F.O. heater 主机燃油加热器44、purif room exh fan分油机室抽风机45、sludge tank 油渣柜46、drinking water hydrophone tank 饮水压力柜47、calorifier 热水柜48、drinking water sterilizer 饮水消毒器49、emergency air compressor50、stern tube gravity oil tank艉管重力油柜51、antifouling system power unit防污系统电源箱52、ECR. Unit cooler 集控室空冷机53、overhead crane 机舱行车54、boiler feed water test kit 炉水试验台55、cylinder oil measuring tank气缸计量柜56、sink 洗池57、gas welder 气焊机58、E.L. welder 电焊机59、universal machine 组合机床60、driller 立式钻床61、bench 钳桌台62、vice台虎钳63、grinder 砂轮机64、cupboard 橱65、sewage treatment unit 生活污水处理装置66、composite boiler 燃油/废气组合锅炉67、forced draft fan 锅炉强力风机68、incinerator焚烧炉69、waste oil service tank 废油日用柜70、supply ventilating fans 送风机71、spark arrester消音器Ⅳ.Others1、shipyard 船厂2、shipbuilding 造船3、berth/slipway 船台4、marine diesel engine 船用柴油机5、bulk-cargo carrier 散装货船6、container ship 集装箱船7、oil tanker 油船8、tonnage 吨位9、merchant ship 民用船10、military ship (warship) 军用船11、drawing 图纸12、hull 船外壳13、bow/stern 船艏/船尾14、port/starboard 左舷/右舷15、deadweight 载重量16、displacement 排水量17、freeboard 干舷18、deck 甲板19、keel 龙骨20、anchor 锚21、rudder 舵22、bottom 底23、supersrtucture 上层建筑24、side25、weld 焊26、painting 油漆27、assemble 装配28、launching29、sea trial 试航30、delivery 交船31、tightness test 密性试验32、after service 售后服务33、approval 认可34、blue collar worker 蓝领35、maker36、rules and regulations 规则、规范37、chief engineer 轮机长38、chief officer大副39、clerk 事务员40、foreigner41、fore peak 艏尖舱42、aft peak 尾尖舱43、frame 肋骨44、cabin 舱室45、wheel house 驾驶室46、shaft tunnel 轴隧47、beam横梁48、manhole 人孔49、bulbous bow球鼻艏50、sea chest 海水门51、bulkhead 隔舱壁52、dry cargo hold 干货舱53、provision store 食品库54、passageway 走廊、通道55、refrigerating chamber 冷藏室Ⅴ甲板机械 Deck Machinery1、deck 甲板2、anchor chain（cable）锚链3、chain locker 锚链舱4、windlass 起锚机5、mooring hole 导缆孔6、bollard 带缆桩7、cargo winch 起货绞车8、hand rail 栏杆9、hawse pipe 锚链筒10、hatchcover 舱口盖11、hatch coaming舱口围板12、control cabin操纵室13、derrick 吊杆14、cargo hook 吊货钩15、mooring winches 系泊绞车16、wire cable 钢索17、vertical ladder 直梯18、wire steel 钢丝卷筒19、side scuttle舷窗20、rudder stock 舵杆21、rudder shaft 舵轴22、flag staff 旗杆23、ventilator 通风筒Ⅵ.管系 for piping1、Exhaust air system 排气系统Exhaust pipe for M.E（Generators / boiler / emergency generators）主机 / 发电机 / 锅炉 / 应急发电机2、Cooling Water System 冷却水系统①cooling fresh water (CFW) 淡水冷却水②cooling sea water (CSW) 海水冷却水3、fuel oil system 燃油系统①light diesel oil②heavy diesel oil (HDO)③fuel oil purifying 燃油净化④oil sludge 废油（污油）⑤fuel oil transferring 燃油输送4、Lubricating oil system①L.O for M.E(generator / stern tube)②Lub. oil transferring5、Compressed air system①high / low pressure air②starting air 起动空气③control air④remote control air 遥控空气⑤miscellanous air 杂用空气6、Ship systems①the bilge system舱底水②the ballast system 压载水③the water supply system 供水④the steam system 蒸汽⑤the drainage system 排水⑥the fire-fighting system 消防⑦the air measuring and filling system 空气测量注入⑧the level system 液位7、filter / filter gauze (screen)8、drainage valve sets9、pressure gauge 压力表9、vacuum真空表10、thermometer 温度计11、steel tube 钢管12、copper tube 铜管13、observation glass 观察镜14、funnel 漏斗15、hose 软管16、induction port 吸口17、bracker 支架18、shim (washer) 垫片19、flange 法兰20、connection 接口21、stainless steel pipe 不锈钢管22、threaded connection 螺纹接头23、sleeve pipe 套管24、flowmeter 流量计25、radiator 散热器26、pipe wrench 管子钳27、spanner 扳手28、pipe cutter 管子割刀29、scraper 刮刀30、vice 老虎钳31、screwdriver 螺丝刀32、torch 手电筒Ⅶ主要阀件铭牌 Main valve list1、slush valve 截止阀2、non-return valve 止回阀3、through-way valve 直通阀4、butterfly valve 蝶阀5、sluice valve 闸阀6、remote-control butterfly valve 遥控蝶阀7、quick closing valve 速关阀8、self-closing valve 自闭阀9、reducer valve 减压阀10、ball valve 球阀11、copper valve 铜阀12、steel valve 钢阀13、cast iron valve 铸铁阀14、stainless steel valve 不锈钢阀15、safety valve 安全阀16、temperature adjusting valve 温度调节阀17、thermostatic valve 恒温阀18、induction valve 进气阀19、exhaust valve排气阀20、drain valve 排泄阀21、fire valve 消防阀22、three-way valve 三通阀23、valve material①cast iron 铸铁②cast steel铸钢③stainless steel④bronze 青铜⑤brass黄铜⑥copper紫铜⑦nodular cast iron球墨铸铁Ⅷ.电力设备 electrical equipment1.emergency (diesel / tacho- / shaft) generator应急（柴油/ 测速/ 轴带）发电机2.servo (governor) motor 伺服（调速）马达3.ignition (current / voltage) transformer点火变压器（电流/电压互换器）4.converter 变流器5.frequency changer 变频器6.charger 充电器7.rectifier 整流器8.uninterrupted power source (UPS)不间断电源装置9.battery or storage battery蓄电池或蓄电池组10.main (emergency / power section) switchboard 主（应急/电力区）配电板11.generator (feeder) panel 发电机（馈电）屏12.charging & discharging panel 充放电板13.(radio / low voltage / internal communication) power distribution board无线电（低压 / 船内通信 / 电力）分电箱14.power unit for cathodic protection阴极保护电源箱15.test panel 电工试验板16.shore connection box 岸电箱17.junction box (with fuse) 接线箱（带熔断器）18.control console (panel) 控制台，集控台19.main engine control stand主机控制台20.motor starter 电动机起动器21.control box (panel) 控制箱（板）22.main engine safety (air conditioning) control box主机安全系统（空调）控制箱23.control box for singal light信号灯控制箱24.steering gear source box 舵机电源箱25.contactor 接触器26.relay 继电器27.control (pressure / change over) switch 控制（压力 / 转换）开关28.magnetic valve 电磁阀29.resistor 电阻器30.push button 按钮31.temperature transducer 温度变换器32.oil mist detector 油雾探测器33.fuse 熔断器34.Ammeter 电流表35.voltmeter 压力表36.power meter 功率表37.power factor meter 功率因数表38.watt-hour meter 电度表39.frequency meter 频率表40.flow meter 流量表41.speed indicator 转速表42.ohm meter 欧姆表43.welder 电焊机the 车床45.drilling machine 钻床46.planning machine 刨床47.grinding machine 砂轮机48.electric heater 电热器49.electric refrigerator 电冰箱50.electric fan 电风扇51.air conditioner 空调52.washing machine 洗衣机53.fresh water sterilizer 引水消毒器54.stator 定子55.rotor 转子56.neutral wire 零线（中性线）57.winding 绕组58.coil 线圈Ⅸ.illumination equipment 照明设备1.port (starboard) light 左右舷灯2.mast 桅灯(stern艉灯 / anchor锚灯 / steering操舵灯 / signal 信号灯 / flashing 闪光灯/ towing 拖船灯/ daylight signal 白昼信号灯/ pendant 舱顶灯/ fluorescent pendant 荧光舱顶灯/ ceiling 蓬顶灯/passage corner 走道角灯/ desk 台灯/ wall 壁灯/ berth 床头灯/ r oom’s nameplate 舱室铭牌灯/ chart table 海图灯/ flameproof 防爆灯/ flood 泛光灯（强光灯）/ search 聚光灯（探照灯）) light3.switch开关4.plug插头5.socket 插座6.socket box 插座箱Ⅹ.Navigation equipment 导航设备1.gyrocompass 电罗径2.magnetic compass 磁罗径3.feedback unit 反馈装置4.echo-sounder 回声测深仪5.log 计程仪6.master (slave) clock 母（子）钟7.radar 雷达8.radio direction finder 无线电测向仪9.Loran (radio navigation / satellite navigation) receiver劳兰（无线电导航 / 卫星导航）接收机10.VHF radio telephone transceiver 甚高频电话收发信机11.facsimile 传真机12.television set 电视机13.video camera 电视摄像机oxygen 氧气acetylene 乙炔nitrogen 氮气inter gas 惰性气体epoxy 环氧的resin 树脂chock楔子垫木soapy water 肥皂水anemometer 风速计manometer 压力（压强）表，气压表straight edge 直尺feeler gauge 塞尺steel scale 钢尺dial gauge 千分表micrometer 外径千分尺vernier caliper 游标卡尺spanner 扳手wrench 扳手screw driver 螺丝刀hammer 锤子clinometer 测斜仪chain block 手拉葫芦mandatory 命令、强制的Chlorinator 氯化器syphon=siphon 弯管，存水管，虹吸管blind 盲板booklet of piping procedure 工序，过程，步骤gymnasium 健身房galley 船上厨房motorcycle safety helmet 安全帽life belt 安全带glove 手套respirator 口罩overall 工作服 uniformelectric torch 手电筒 flashligheyeglass 眼镜elevator 电梯plank 厚木板stage 大舞台expressions 公式 formula（复数formulae）plus 加，正minus 减，负multiply 乘divide by 用…除equal to 等于sb entrust sb with sth 委托某人reply to 答复promise 许诺explanation 解释说明answer to 答案typist 打字员triangle 三角形quadrangle 四边形四角形pentagon 五角形inflator 打气筒tyre 轮胎wheel 车轮off duty 下班on duty 上班overtime 加班Slipway、shipway船台1.Lighting alignment for shafting & rudder system 轴舵系照光对中2.Stern tube boring 艉轴管镗孔3.Stern tube bush 艉轴衬套4.Stern boss艉轴壳5.forced fitting inspection压入配合检验6.oil jack（千斤顶）油泵7.（propeller shaft & stern tube bush）radial clearance （艉轴和艉管衬套）径向间隙8.axial clearance 轴向间隙9.Stern tube seals sealing 艉轴密封10. propeller installation force fitting压配11.pull-up length压进距离12.pull-up force 推进力13.oilpressure for boss 扩涨油压14.Zero point 零点15. Shrinkage 过盈量16.cleanness光洁度17.taper圆锥，斜度18. superposition 重合19. intersect 相交20.perpendicularity 垂直度21.vertical垂直的22.horizontal 水平的23. nut of stern shaft艉轴螺栓24.rudder 舵25.rudder blade 舵叶26.rudder stock 舵杆27.rudder pintle 舵销28.rudder tiller 舵柄29.rudder bush 舵承30.rudder horn 挂舵臂31. securing key 定位销，定位键32.protecting cover 保护帽33.grease牛油34.rudder angle 舵角35.full angle 满舵36. rudder blade’s stopper 防跳块37.temperature sensor 温度传感器38. inlet outlet 进出39. tolerance 公差，允许量40.wear down gauge 磨损规41.stern tube main chamber 大腔42.high pressure chamber 高压腔43.low pressure chamber 低压腔Engine Room 机舱1.Cleaning check：Storage oil tank of steering gear 舵机储存油箱（方形）Expansion oil tank of mooring winch 绞机膨胀油箱（圆形）Storage oil tank of mooring winch 绞机储存油箱Storage oil tank of windlass 锚机储存油箱（方形）Expansion oil tank of windlass 锚机膨胀油箱（圆形）Hydraulic oil tank of hatch cover 舱口盖液压油箱2.flushing of winch piping 绞机管路投油1.D/G pouring epoxy chock 发电机浇环氧2.holding down bolt 地脚螺栓3. deflection of crankshaft 曲轴甩档4.piston 活塞5.cylinder 气缸6. turbocharger 涡轮增压器1.Force measurement of M/E stay bolts 紧固螺栓2.piston rod and connection rod bolts 活塞杆和连杆螺栓3.bolts in drive end of crank 曲轴大端螺栓4.piston—piston rod—crosshead—connection rod—crank—crankshaft活塞活塞杆十字头连杆曲柄曲轴5.cam 凸轮6.camshaft 凸轮轴7.M/E chain cable 主机链条8.flooding test of M/E return oil pipes 压水试验9.propeller cap—propeller—stern tube seals—stern tube bush—stern shaft—intermediate shaft导流帽螺旋桨艉密封艉管衬套艉轴中间轴—intermediate bearing—flywheel (thrust shaft)中间轴承飞轮推力轴10.coupling reamer holes 联轴节铰制孔11.turning gear 盘车机12. spring 弹簧1.main air compressor 主空压机2.alignment of coupling flange 联轴节对中3.gap 裂面4.sag 位移1.steering gear 舵机2. ram roller bearing 舵机活塞杆轴承3. neck bush & cylinder 舵机活塞颈衬套和活塞缸体4. dimension measurement 尺寸测量1.fore draft valve艏吃水阀2.speed log 计程仪3.echo sounder 测深仪Quay、shipside、wharf、dock码头感谢阅读，这里是龙de船人获取更多资讯，请关注后输入关键字搜索投稿、建议、沟通：*****************。
轮机英语翻译课文
LESSON 1Diesel enginesThe majority of ships around the world continue to be powered exclusively by diesel engines.世界范围内大多数船舶都是采用柴油机作为动力。
The predominance of diesel engines has come from improved engine efficiencies and designs compared to other forms of propulsion such as steam or gas turbines.与蒸汽机、燃气轮机等形式的动力装置相比，无论是效率上的提高，还是设计上的进步，柴油机都体现出了一定的优势。
Many combinations and configurations of diesel engine power plant exist. All provide the energy to do the work of moving the ship using diesel engines.存在有很多种联合形式及结构形式的柴油机动力装置，他们都能够利用柴油机为船舶提供推动力。
Slow speed diesel engines 低速柴油机Slow speed diesel engines are large, especially tall, and heavy and operate on the two-stroke cycle.低速柴油机是体积较大、缸体较长、机身较重的二冲程柴油机。
These are the largest diesel engines ever built. Engine powers up to 100 000kw are available from a single engine.它们是已建造过的最大型的柴油机，它们的单机可用功率可达100000 kw。
轮机英语lesson 16
He xueming
China Maritime Police Academy
• Also，in the case of water cooled condensers，fresh water or sea water may be employed．Fresh water is usual when a central fresh water／sea water heat exchanger is employed for all engine room requirements．
• 船舶制冷装置通常应用的是蒸汽压缩式制冷 循环，基本原理如图16-1所示。
He xueming
China Maritime Police Academy
Fig．16-1 Marine vapor compression refrigerating system
1. Compressor；2. Oil separator；3. Condenser 4.liquid receiver；5. Drier and filter；6. Solenoid valve；7. Temperature controller；8．Expansion vave (with sensing bulb)； 9．Evaporator；10. Non-return valve；11. Evaporating pressure regulator；12. Bypass capacity regulator；13，14．High and low pressure controller；15．Differential pressure controller；16．Releasing valve；17．Condensing pressure regulator；18．Charging valve；19，20，21，22，23．storage room for meat，fish，beverage，milk，vegetable
新版轮机英语unit16
Depending on the particular application, the refrigerant gas will be cooled either by air or water, and because it is still at a high pressure it will condense（冷凝）
The refrigerant must also be free from toxic（有毒的）, explosive, flammable and corrosive properties where possible
Some refrigerants have critical temperatures（临界温度） above which the refrigerant gas will not condense
This was one of the disadvantages of carbon dioxide, which was used for many years on ship
Ships operating in areas with very high sea water temperatures had difficulty in liquefying the carbon dioxide without some additional sub-cooling system
Where this is the case, because of the higher cooling water temperature to the condenser, delivery temperatures from condensers will be higher than that on a sea water cooling system
轮机英语
船舶航海英语词汇Ranks of ship’s crew(船员职务)crew 船员captain（master）船长chief officer 大副or chief mate（first mate）second chief 二副or second matethird officer 三副or third mateassistant officer 驾助radio officer（radio 报务员operator, wireless operator）purser (chief purser) 管事,事物长clerk 事务员boatswain or bosun 水手长cassab 副水手长quartermaster 舵工coxswain 舵工,艇长able seaman 全能水手,一水a.b.(able bodied seaman) 全能水手e. D.h. , d.h.u. 全能水手o.s.(ordinary seaman) 普通水手,二水seaman, mariner 普通水手,海员deck boy 甲板员engineer 轮机员chief engineer 轮机长,大车,老轨second engineer 大管轮,二车,二轨third engineer 二管轮,三车,三轨fourth engineer 三管轮,四车,四轨assistant engineer 轮助mechanic 机工fireman 生火cleaner or wiper 清洁工chief steward 大管事(or catering officer)second steward 二管事chief cook 大厨second cook 二厨supernumerary 额外人员ship’scomplement 船上的定员deck serang 水手长deck tindal 副水手长seacunny 舵工Names of marine organizations and their( 船务机关名称及工作人员)harbour administration bureau (or harbour bureau) 港务局the joint inspection party-inward and outward 进口联合检查组harbour supervision office 港务监督the customs 海关frontier inspection station 边防检查站quarantine office (s0ervice) 卫生检疫所animal and plant quarantine service 动植物检疫所china commodity inspection and testing bureau(ccitb) 中国商品检验局china marine bunker supply corporation 中国船舶燃料供应公司china national chartering corporation(zhongzu) 中国租船公司china ocean shipping agency 中国外轮代理公司china ocean shipping company (cosco) 中国远洋运输公司china ocean shipping company chartering department(coschard)中国远洋轮船公司租船部 (“中远租”)chian ocean shipping tally company 中国外轮理货公司china ocean shipping supply corporation(supco.) 中国外轮供应公司the ~ office of the register of shipping of the people’s republic of china 中华人民共和国船舶检验局~办事处joint inspection party 联检小组customs officer 海关官员harbour officer 港务监督员frontier defence officer (inspector ,guard) 边防检查组Quarantine officer(dotor) 卫生检疫员customs boarding office 登轮官员customs searching party 海关检查组docker 码头工人(广义)longshoreman 码头工人(在岸上装卸)stevedore 码头工人(在船上装卸)foreman 装卸队长pilot 引水员cargo surveyor 商品检验员marine or ship surveyor 验船师chief tallyman 理货员waterman 加水工人agent 代理Marine loading and discharging gear and harbour facilities（海运装卸机械工具和港口设施）barge 驳船beacon 航标灯belt conveyor 皮带运输机board palnk 木版bridge crane 桥吊，装卸桥bunkering tanker 供燃料船buoy 浮筒，浮标can hook，barrel sling 吊桶钩canvas 帆布canvas sling 吊货帆布袋cargo tray 吊货盘cargo runner 吊货钢丝绳chafing plate 防擦板chafing mat 防擦席chain sling 链条吊索crane 吊车cold storage 冷藏仓库conveyor belt 传送带crowbar 撬杠customs launch 海关关艇dolphin 系缆桩dunnage 垫仓物料electric crane 电吊elevator 升降机ferry boat 轮渡船fire boat 消防船floating crane 浮吊footboard 踏板fork - lift 铲车，叉车funnel 漏斗gangboard 跳板gantry crane 龙门吊garbage(sludge,sewage) boat 垃圾船grab 抓斗grain elevator 吸粮机hammer 铁锤handcart 手推车harbour light 港口灯标iron nail 铁钉landing pier 登岸码头lifting maget 西铁吊具lighter 驳船light house 灯塔light ship 灯船manila rope 白棕绳mat 席子mobile crane 流动吊车mooring anchorage 系泊锚地mooring buoy 系泊浮筒motor launch 小汽艇nylon rope 尼龙绳oil hose 输油软管open yard 露天货场personnelboat 交通艇pilot boat 引水船plate hook 钢板吊钩pontoon 浮码头pontoon bridge 浮桥quarantine anchorage 检疫锚地quarantine vessel 检疫船refrigerator car 冷藏车rope sling 绳吊索saw 锯semi-portal crane 半门吊shifting board 防动板signal tower 信号台steam launch 小汽艇steel wire 钢丝绳tower crane 塔吊tractor 牵引车traffic boat 交通艇tug boat(motor tug) 拖轮warehouse 仓库water boat 供水船watr lever indicator 水深标尺wire cargo net 钢丝网络wire sling 钢丝吊索various kind of vessels（各种船舶）air cushion craft 气垫船bage-carrier 载驳货船bulb-bowed ship 球鼻首船bulk-carrier 散货船cargo liner 定期货船collier 散货船crew boat （船员）联络船diesel boat 柴油机船dry cargo ship 干货船dumb lighter 驳船（没有机器的）freighter 货船oil barge 油驳ore carrier（ore ship）矿砂船reefer（refrigerator ship）冷冻船salvage vessel 救助船grain carrier 运量船light ship 未载货的货船lumber carrier（timber carrier）运木船meat ship 肉类船moto ship 内燃机船ocean-going vessel 远洋船sister ship 姐妹船steam ship 蒸汽机船stor carrier 补给船tanker（oil tanker）油驳trawler 拖网渔船Major marine papers and certificates（主要船务单据及证书）（1）papers单据application for bunkers 加(燃油)申请书application for tallyman 理货申请书bill of lading 提单booking note 订舱单boat note 订载单cargo receipt 交货收据cargo tally sheet 理货记数单copy 副本damaged cargo report 货物残损报告书declaration 申报单delivery order 交货单dock receipt 码头收据gang record 工班报单hatch(cargo)list 分舱单inward manifest 进口舱单license 许可证mate’s receipt 收货单notice of arrival 到货通知书motice of claim 索赔通知notice of readiness 准备就绪通知书on-spot record 现场记录original 正本outward manifest 出口舱单parcel receipt 小包收据sailing orders 开航通知shipper’s export declaration 货物出口申请书shipping list 装货通知书shipping permit 准运单short/overlanded cargo list 货物溢短单short/overlanded cargo report 货物溢短报告单tally daily report 理货日报告tally shift report 理货工班报告2 )certificates ( 证书,证件)certificate of freeboard 干舷证书certificate of health 无疫证书certificate of origin 产地证书ceitificate of port registry 船籍港证书certicficate of survey 船舶检验证classification certificate 船级证书deratting certificate 除鼠证书deratting exemption certificate 免予除鼠证书inspection certificate 验讫单international loading certificate 国际载重线证书maritime declaration of health 航海健康申明书navigation certificate seaworthiness certificate 适行证书outward clearance certificate 出国证书panama canal tonnage certificate巴拿马运河吨位证书passport 护照safety radio telegraphy certificate无线电报安全证书ship’s safety certificate 船舶安全证书sues canal special tonnage certificate 苏伊士运河专用吨位证书tonnage certificate 吨位证书tonnage dues certificate 吨税证书wireless inspection certificate 无线电安全证书The structure of a ship(船舶结构)accomodation 房间accomodation ladder 舷梯aerial(antenna) 天线aft part(after part) 船尾部after-peak 后尖舱air siren 汽笛aldis lamp 闪光信号灯alleyway 走道anchor 锚anchor chain 锚链auxiliary machinery 辅机bilge 船底沟binnacle 罗盘支架bitts(bollards) 系缆柱block 滑轮boom 吊杆bow 船头port bow 左舷船头starboard bow 右舷船头break 夹板台阶bridge 船桥,驾驶台brow (从船上到岸上的)舷梯bulwarks 舷墙bunker 燃料舱cabin 船舱pilot’s cabin 引水员房间cable 锚链capstan 绞盘cargo hold 货舱catwalk 狭窄的舷梯awning 帆布蓬baggage room 行李房barometer 气压表basic line 吨位标志线balk(blulk) , beam 船梁hatch beam 舱盖横梁port beam 左舷starboard beam 右舷chain locker 锚链舱chronometer 经纬仪coamings 舱口栏板compass 罗盘course recorder 航向记录仪crane 起重机davit 挂艇架deck 甲板boat deck 救生艇甲板lower deck 下甲板lower tween deck 二层柜main deck 正甲板poop deck 船尾上面的甲板promenade deck 保护甲板之上甲板shelter deck 遮蔽甲板tonnage deck 量吨甲板tween(between)deck 二层柜upper deck 上甲板upper tween deck 三层柜deck house 甲板室derrick 吊杆diesel engine 柴油机double bottom 双层底draught marks(draft marks) 吃水标志dynamo(generator) 发电机echo sounder 测深仪engine roon 机舱engin roon department 机舱部escape trunk 救生道fan room 打风间falg-staff 旗杆forecastle 船首楼forecastle head 船头甲板foremast 头柜forepart 船头部forepeak 前尖舱freeboard deckling 干舷甲板线gangway 舷梯glass (口语)气压表guy 稳索gyro compass(gyro) 电罗经halliard ,halyard 旗帜之升降索hatch 舱口hatch bord 舱盖板hatch coaming 舱口栏板hatch cover 舱口盖hawse hole 锚链孔helm 舵轮;舵柄hawser 船缆;锚链hull 舱壳jack ladder(jacob’s ladder)软梯,绳梯jackstaff 船头小旗杆jigger mast 尾jumbo(derrick 重吊(杆) keel 龙骨life belt 救生带life bort 救生艇life buoy 救生圈life jacket 救生衣life raft 救生筏life-saving apparatus 救生设备load ling 载重线,装载水线mainmastman-rope 绳索mizzen mastmonkey island 瞭望台pilot ladder 领港梯子piston 活塞plimsol’s mark 载重线标志poop 船尾楼port 港口,舱口,左舷port -hole 舷舱,舱口propeller 螺旋桨pulley 滑轮pump 水泵purchase 绳索,滑轮quarter 船舷的后部port quarter 左舷后部starboard quarter 右舷后部radar 雷达radio 无线电radio direction finder 无线电测向器radio room 无线电室radio transmitter 无线电发射机rast 救生筏rail,railings 扶手,栏杆rat-guard 缆绳上的防鼠隔ratlines 绳梯横索refrigerated hold 冷藏舱rig 帆索rudder 舵screw 螺丝钉scupper 排水管scupper board 挡水板scanner 雷达扫描设备sextant 六分仪shaft tunnel 地轴弄shackle 钩环shifting board 防动板,防舱板signal rocket 信号火箭siren 汽笛sling 吊索starboard 右舷steam engine 蒸汽引擎steering gear 舵机stem 船头stern 船尾storeroom 贮藏室tackle 滑车,吊具tank 液体舱ballast tank 压载水舱cofferdam tank 隔离沧deep tank 深舱，深水柜。
轮机英语带音标
轮机英语词汇，带音标Aabnormal[æb’nэ:m(∂)l] adj. 反常的, 变态的 ,不正常的,abrasive [∂‘breısıv] adj.使磨损的, 粗糙的, (n.) 研磨料.absolute [‘æbs∂lu:t] adj. 完全的, 绝对的,静的。
acceleration [∂ksel∂reı(∂)n] n. 加速度.变速，过载。
accurate [‘ækjύr∂t] adj. 准确的, 精确的.精密的，已校准的,acetylene [∂‘set∂li:n] n. [化] 乙炔, 电气石.acid [‘æsıd] n. [化]酸, <俚>迷幻药, (adj.) 酸的,酸性的,act [ækt] vi. 行动，产生...的效果. (n.) 行为，法令，节目。
activator [`æktıveıt∂(r)] n. [化]催化剂，激励器，抖动器。
add [æd] v. 増加，添加，合计，累计.additive [∂’dıtıv] n.添加剂。
(adj.) 附加的，添加的.adhesive [∂d’hi:sıv] n.粘合剂，胶布。
(adj..) 粘着的，胶粘的，adjustable [∂’dЗ۸st∂b(∂)l] adj 可调整的；可调节的advicee [∂d’vaıs] n.忠告，建议，通知。
alarm [∂lа:m] n. 警报，警报器，报警装置。
alignment [∂’laınm∂nt] n. 队列，校直，调正，调准，定线。
alkaline [`ælk∂laın] adj.[化]碱的，碱性的。
allow [∂’laύ] vt.准许，许可，承认，打算。
allowance [∂’laύ∂ns] n. 津贴，补助，宽容，余量，容限，容差，公差。
alloy [‘ælэı] n. 合金。
轮机英语教学课件(16) Marine Boilers
Main stem stop valve: usually fitted in the main steam supply line and is usually of the non-return type.
在许多船上通过废热回收装置由蒸汽涡轮发动机发 电和向加热设备供应饱和蒸汽均有应用。
该句为主系表结构，is之前皆为主语。
Review Questions
1.What are the two types of marine boilers and what are the differences between them?
Main Contents of the Text
Types of boiler Firetube boilers and watertube boilers Boiler mountings Safety valves Main steam stop valve Water level gauge Waste heat recovery system
2. What is bent tube design? 3.What is donkey boiler and its
function? 4.What is waste-heat boiler？
Scum valve: a shallow dish positioned at the normal water level is connected to the scum valve. This enables the blowing down or removal of scum and impurities from the water surface.
轮机英语词汇汇总知识讲解
轮机英语词汇汇总一．职位及工种(Titles and type of work) 1．船长 Captain2．大副 Chief officer3．二副 Second officer4．三副 Third officer5．四副 Fourth officer6．水手长 Boatswain7．水手 Sailor & Seaman8．木匠 Carpenter9．轮机长 Chief engineer10．大管轮 Second engineer11．二管轮 Third engineer12．三管轮 Fourth engineer13．机匠长 Chief motorman15．机匠 Fitter16．加油工 Oil man17．大电 Chief electrician18．电工 Electrician19．车间主任 Workshop director20．工长 Section chief21．班长 Fore man22．钳工 Fitter23．主管工程师 Engineer in charge24．机务&船东 Superintendent &Super &Owner 25．助理工程师 Assistant engineer26．验船师（机）Register27．验船师（船）Surveyor28．油漆工 Painter29．焊工 Welder30．大橱 Chief cook31．物料员 Store keeper32．加油工 Oiler33．机工 Mechanic34．甲板员 Deck man35．电线工 Wireman36．外包工 Laborer37．铸工 Molder38．管子工 Pipe fitter39．起重工 Crane operator二、柴油机类(Words about diesel engine) 1．主机 Main engine2．二冲程柴 Twostrokediesel engine3．四冲程柴 Forestrokediesel engine4．高速柴油 High speed diesel engine5．中速柴油 Middle speed diesel engine6．低速柴油机 Low speed diesel engine7．气缸盖(缸头) Cylinder head8．安全阀 Safety valve9．释放阀 Relief valve10．示功阀 Indicator valve11．示功考克 Indicator cock12．空气起动阀 Air starting valve13．起动空气分配器 Air starting distributor 14．油头(燃油喷射器) Fuel injector15．排气阀 Exhaust valve16．气缸套 Cylinder liner17．冷却水套 Cooling water jacket18．气缸注油器 Cylinder lubricator19．活塞 Piston20．活塞头 Piston crown21．活塞裙 Piston skirt22．活塞销 Piston gudgeon pin24．活塞杆 Piston rod25．活塞环 Piston ring26．活塞环槽 Piston ring groove27．压缩环 (气环) Compression ring28．刮油环 (油环) Oil scraper ring29．减磨令 Wear ring (copper ring)30．伸缩管(水拉管) Telescopic pipe31．活塞冷却空间 Piston cooling space32．填料箱(函) Stuffing box33．填料箱密封环 Sealing ring for Stuffing box 34．填料箱压缩环 Pressure ring for Stuffing box 35．填料箱刮油环 Scraper ring for Stuffing box 36．扫气箱 Scavenging receiver37．扫气口 Scavenging port38．排气口 Exhaust port39．十字头 Cross head40．十字头销 Crosshead pin41．十字头轴承 Crosshead bearing42．十字头滑块 Crosshead slipper43．滑块 Guide shoe44．十字头导板 Crosshead guide plate45．连杆 Connecting rod46．连杆大端轴承 Bid end bearing47．连杆小端轴承 Small end bearing48．曲柄轴承 Crank bearing49．曲柄销 Crank pin50．曲轴 Crank shaft51．曲轴颈 Crank journal52．曲柄臂 Crank web53．拐档差 Crank deflection54．主轴承 Main bearing55．主轴颈 Main journal56．轴承瓦 Bearing bush57．上轴瓦 Upper bearing bush58．上轴瓦 Upper half59．下轴瓦 Lower bearing bush60．下轴瓦 Lower half61．推力轴承 Thrust bearing62．推力块 Thrust pad63．推力盘 Thrust disc64．推力轴 Thrust shaft65．底座 Bed plate66．机架 Frame67．曲柄箱 Crank case68．曲柄箱导门 Crank case door69．曲柄箱防爆门 ExplosionproofCrank case.70．定时齿轮 Timing gear71．飞轮 Flying wheel72．凸轮 Cam73．凸轮轴 Cam shaft74．喷油凸轮 Fuel injection cam75．链条 Chain76．链条轮 Chain wheel77．链条箱 Chain box78．推杆 Push rod79．摇臂 Rocker arm80．排气阀 Exhaust valve81．吸气阀 Suction valve82．排气总管 Exhaust manifold83．进气总管 Air inlet manifold84．高压燃油管 High pressure fuel pipe 85．活塞冷却水管 Piston cooling water pipe 86．法兰 Flange87．贯穿螺栓 Tie bolt (tie rod)88．端盖 Side cover89．滑油泵 Lubricating oil pump90．燃油泵 Fuel oil pump91．滑油泵齿轮 Gear for lubricating oil pump 92．燃油泵齿轮 Gear for fuel oil pump93．叶轮 Impeller94．柱塞 Plunger95．导杆 Guide rod96．导套 Sleeve97．滚动轴承 Ball bearing98．滑动轴承 Sliding bearing99．推力滚动轴承 Thrust ball bearing100．推力面 Thrust surface (thrust side) 101．盘车机 Turning gear102．增压器 Turbocharger103．涡轮机(透平) Turbine104．涡轮 Turbine wheel105．涡轮叶片 Turbine blade106．喷嘴 Nozzle107．废气叶轮 Exhaust impeller108．废气叶轮片 Exhaust blade109．废气端 Exhaust side110．透平端 Turbine side111．转子轴 Rotor shaft112．油泵 L.O. pump113．换向装置 Reversing device114．换向伺服期 Reversing servomotor115．压气机(鼓风机) Blower116．膨胀接 Expansion joint117．调速器 governor118．飞重 Flying weight119．补偿阀 Compensate valve120．针阀 Needle valve121．开口销 Cotter pin122．轴封 Shaft seal123．机械密封 Machinery seal124．配电盘 Switchboard125．应急配电盘 Emergency switchboard 126．应急发电机 Emergency generator127．滤器 Filter128．细滤器 Filter129．粗滤器 Strainer130．滑油滤器 L.O. filter131．燃油滤器 F.O. filter132．空气消音器 Air intake silencer132．空气滤器 Air intake filter133．空气瓶 Air bottle (receiver)134．分油机 Separator135．油水分离器 Wateroil separator136．净油机 Purifier137．燃油净化器 F.O. purifier138．二氧化碳 CO2139．二氧化碳瓶 CO2 bottle140．正时齿轮 Timing gear141．导向棒装置 Guide bar142．注油器驱动 Lubricator driver143．链条张紧装置 Chain tightener144．凸轮轴传动轮 Chain wheel on cam shaft 145．中间链链传动轮 Intermediate chain wheel 146．注油器驱动装置 Lubricator drive147．链条张紧装置 Chain tightener148．滚筒导座 Roller guide housing149．应急操纵台 Emergency console150．力矩平衡器 Moment compensator151．主启动阀 Main starting valve152．启动空气分配器 Starting air distributor 153．喷油器 Fuel valve154．扫气系统 Scavenge air system155．安全帽 Safety cap156．机座 Bed plate157．轴向振动减振器 Axial vibration damper158 贯穿螺栓 Arrangement of stay bolt159．示功器驱动装置 Indicator driver160．端罩 End shields161．气缸架 Cylinder frame162 气阀传动装置 Valve operating device163．摇臂润滑油泵 Rocker arm lubricating oil pump 164．摇臂润滑油柜 Rocker arm lubricating tank 165．摇臂润滑滤器 Rocker arm lubricating filter 三、船舶机械类(Words about marinemachinery)1．船用锅炉 Marine boiler2．废气锅炉 Exhaust boiler3．辅锅炉 Donkey boiler4．组合式锅炉 Combined boiler5．火管 Fire tube6．给水管 Feed pipe7．炉膛 Furnace8．炉墙 Furnace wall9．火侧 Fire side10．水侧 Water side11．燃烧器 Oil burner12．安全阀 Safety valve13．上排污 Upper drain14．下排污 Lower drain15．锅炉皮阀 Mounting valve16．水位计 Water level gauge17．压力表 Pressure gauge18．主汽门 Main steam valve19．玻璃管 Glass tube20．空调装置 Airconditioning plant21．制冷装置 Refrigerating plant22．冰机 Fridge. Machine23．空气压缩机 Air compressor24．造水机 Fresh water generator25．板式冷却器 Plate type cooler26．机舱天车 Engine room crane27．天车导轨 Crane rail28．电磁阀 Solenoid valve29．舵机 Steering gear30．舵承 Rudder bearing carrier31．液压缸 Hydraulic cylinder32．废气涡轮增压器 Exhaust gas turbocharger 33．弹簧阀 Spring loaded valve34．冷凝器 Condenser35．分油器 Oil separator36．轴带发电机 Shaft generator37．焚烧炉 Oil burner38．分油机 Separator39．分离筒 Separator bowl40．配水盘装置 Paring disc device41．转数计 Revolution counter42．控制阀 Control valve43．辅机 Auxiliary machinery44．制冷装置 Refrigerating plant45．海水淡化装置 Sea water desalting plant 46．热交换器 Heat exchanger47．船用气瓶 Marine air bottle48．冷风机 Cooler unit49．防水风门 Fire damper50．气密挡板 Gas tight damper51．排气风机 Exhaust fan52．舱室通风机 Cabin fan53．机舱通风机 Engine room fan54．应急鼓风机 Emergency blower四、阀门(Words about valve)1．吸气阀 Suction valve2．排气阀 Exhaust valve3．控制阀 Control valve4．导阀 Pilot valve5．单向阀 Nonreturn valve6．口琴阀 Flap valve7．调节阀 Regulating valve8．液压阀 Hydraulic valve9．膨胀阀 Expansion valve10．给水阀 Feed valve11．排水阀 Discharge valve12．截止阀 Stop valve13．吹泄阀 Blowoff valve14．空气阀 Air valve15．泄放阀 Drain valve16．止回阀 Check valve17．海底阀 Sea valve18．回流阀 Retune valve19．节流阀 Throttle valve20．进气阀 Inlet valve21．出气阀 Outlet valve22．热力阀 Thermal valve23．中央阀 Center valve24．单向阀 One way valve25．二通阀 Two way valve26．三通阀 Triple valve27．旁通阀 Bypass valve28．换向阀 Changeover valve30．溢流阀 Overflow valve31．自闭阀 Selflocking valve32．针阀 Needle valve33．平衡阀 Balance valve34．循环阀 Circulation valve35．主阀 Main valve36．滑阀 Slide valve37．蝶阀 Butterflyvalve38．截止阀 Shutoffvalve39．闸板阀 Gate valve40．通海阀 Sea suction valve41．吹除阀 Sea chest cleaning valve 42．防浪阀 Storm valve43．舱壁阀 Bulkhead valve44．快关阀 Emergency shut off valve 45．呼吸阀 Breather valve五、泵类(Words about pump)1．电动泵 Motordrivenpump2．柱塞泵 Plunger pump3．叶片泵 Vane pump4．回转泵 Rotary pump5．齿轮泵 Gear pump6．往复泵 Reciprocating pump7．离心泵 Centrifugal pump8．真空泵 Vacuum pump9．螺杆泵 Screw pump10．喷射泵 Ejector pump11．冷却泵 Cooling pump12．淡水泵 Fresh water pump13．海水泵 Sea water pump14．给水泵 Feed water pump15．循环泵 Circulating pump16．锅炉给水泵 Boiler feed pump 17．卫生水泵 Sanitary pump18．压载泵 Ballast pump19．舱底泵 Bilge pump20．污水泵 Sewage pump21．燃油泵 Fuel pump22．高压油泵 High pressure pump 23．低压油泵 Low pressure pump 24．驳运泵 Transfer pump25．增压泵 Booster pump26．消防泵 Fire pump27．通用泵 G.S. pump28．旋涡泵 Regenerative29．蜗壳泵 Volute pump30．导叶泵 Diffuser pump31．单联泵 Simplex pump32．双联泵 Duplex pump33．多联泵 Multiplex pump34．活塞泵 Piston pump35．减摇泵 Antirollpump36．总用泵 General service pump 37．应急消防泵 Emergency fire pump 38．扫舱泵 Stripping pump39．货油泵 Cargo oil pump 40．滑油泵 Lubricating oil pump 六、甲板机械类（Deck machinery）1．锚机 Windlass2．锚机轴 Windlass shaft3．刹车带 Brake lining4．离合器 Clutch5．锚链轮 Anchor Chain wheel 6．轴承瓦 Bearing bush7．轴承盖 Bearing cover8．绞揽机 Capstan9．系揽绞车 Mooring winch 10．卷缆车 Reel 个11．钢丝绳 Wire rope12．卡环 Shackle13．缆绳 Mooring rope14．滑轮 Block15．刹车装置 Brake device 16．制链器 Anchor chain stopper 17．舱盖滚轮 Hatch cover wheel 18．舱盖铰链 Hatch cover hinge 19．液压油缸 Hydraulic jack 20．起货机 Cargo winch21．克令吊 Crane22．生活吊 Accommodation crane 23．吊杆 Derrick boom24．桅杆 Mast25．救生艇 Lifeboat26．艇架 Davit27．艇机 Lifeboat capstan 28．救生筏 Life raft29．救生衣 Life jacket七、工具类(Word about tools) 1．车床 Lathe2．刨床 Planing machine3．钻床 Drill machine4．砂轮机 Grinding machine 5．磨床 Grinder6．铣床 Milling machine7．镗床 Boring machine8．手锤 Engineer’s hammer 9．冲击板手 Impact wrench 10．板手 Spanner11．活络板手 Screw spanner12．梅花板手 Ring spanner13．呆扳手 Open spanner15．套筒板手 Socket spanner16．管子钳 Pipe spanner17．螺丝刀 Screw driver18．钢丝钳 Wire pliers19．尖嘴钳 Long nose pliers20．钢锯 Hack saw21．剪刀 Scissors22．手电筒 Torch23．扁铲(凿子) Chisel24．锉刀 File25．丝攻 Thread tap26．板牙 Thread die27．绞刀 Reamer28．刮刀 Scraper29．油石 Oil stone30．拔子(拉马) Puller31．沙布 Emery cloth32．破布 Rag33．卷尺 Measuring tape34．空心冲 Hole punch35．样冲 Joint punch36．油壶 Oil gun37．牛油枪 Grease gun38．手电钻 Handle drill39．钻头 Drill40．液压千斤 Hydraulic jack.41．塞尺 Feeler gauge42．游标卡尺 Vernier caliper43．外卡尺 Outside calipers44．内卡尺 Inside calipers45．螺纹量规 Screw gauge46．桥规 Bridge gauge47．电焊机 Electrode welding machine 48．气焊机 Gas welding machine 49．电焊钳 Electric welding pliers 50．气割枪 Cutting touch51．电焊条 Electric soldering iron 52．电工刀 Electrician knife53．电笔 Test pen54．剥线钳 Wire stripping pliers 55．圆规 Compass56．量表 Gauge57．拐档表 Crank deflection gauge58．深度规 Depth gauge59．千分表 Micrometer gauge60．台虎钳 Table vice61．柴油 Diesel oil62．滑油 Lubricating oil63．液压油 Hydraulic oil64．重油 Heavy oil65．燃油 Fuel oil66．黄油 Grease67．螺栓 Bolt68．螺帽 Nut69．垫片 Washer70．研磨沙 Grinding sand71．研磨膏 Grinding paste72．石棉板 Asbestos plate73．青壳纸 Fish paper74．盘根 Packing75．细钢丝 Thin steel wire76．密封圈 Rubber seal ring77．塑料管 Plastic pipe78．胶皮管 Rubber hose79．电灯泡 Electric bulb80．工作灯 Working lamp81．插头 Electric plug82．插座 Electric socket.93．喷砂机 Sand blaster outfit94．空气马达 Air motor95 油柜清洁器 Tank cleaning machine96．高压冲水机 High pressure hose for hydraulic 97．真空泵 Vacuum pump98．套筒扳手组 Socket wrench set99．深头套筒 Deep socket wrench100．套筒扳手 Box wrench101 单开口扳手 Single open end wrench102．双开口扳手 Double open end wrench103．转矩扳手 Torque wrench104．电动机扳手 Motor wrench105．侧剪钳 Slide cutting plier106．活节钳 Combination plier107．可调快速扳手 Speed wrench108．螺丝起子 Screwdriver109．偏向螺丝起子 Offset screw110．六角螺帽起子组 Hexagon nut drivers set111．手摇钻 Straight hand drill112．手工锯 Hacksaw frame113．锯片 Hacksaw blade114．砂纸 Silicon paper115．手拉葫芦 Chain block116．高压管 High pressure hose117．液压千金顶 Hydraulic jack118．锤子 Hammer119．平錾 Cold chisel120．活动扳手 Adjustable wrench121．螺丝刀 Screwdriver122．侧剪铗 Side cutting hipper123．螺栓剪 Cable cutter124．敲击管钳 Rap wrench125．砂轮 Grinding wheel126．老虎钳 Utility vise127．直梯 Straight ladder128．踏梯 Step ladder129．平台推车 Platform trunk130．搬平车 Gas cylinder carrier131．给油机 Grease lubricator132．强力油泵 Heavy duty pump oiler133．油壶 Oil jag134．麻花钻 Twist drill135．绞刀 Pin reamer136．旋转中心钻 Rolling center137 ．外径测微计 Outside micrometer with counter 138．六折式尺 Sixfolding rule139．弹性带尺 Convex rule140．不锈钢直尺 Stainless steel straight rule 141．平面规 Surface gauge142．平行直角定规 Precision flat try square 143．温度计 Thermometer八、常用物料(Material in common use)1．阀研磨剂 valve grinding compound2．电焊条 steel electrode3．气焊条 Steel welding wire4．细钢丝绳 Seizing wire5．刚焊条 Steel welding rod6．紫铜管 Copper tube7．乙炔气瓶 Acetylene cylinder8．木屑 Saw dust9．水泥 Cement10．石灰 Lime11．帆布手套 Canvas glove12．垫片 Gasket.13．氧气瓶 Oxygen cylinder14．抹布 Rag15．垫隙片 Shim16．电线 Wire17．电缆 Electric cylinder18．电池 Rag19．灯泡 Bulb20．胶布 Insulating tape21．插头 Plug22．插座 Socket23．保险丝 Fuse24．不锈钢 Stainless steel25．铸铁 Cast iron26．黄铜 Brass27．青铜 Bronze28．铝合金 Aluminium alloy29．橡胶 Rubber30．石棉 Asbestus31．低碳钢 Soft steel32．高碳钢 Highcarbon steel33．合金钢 Alloy steel34．木材 Wood35．塑料 Plastic36．球墨铸铁 Nodular iron九、常用紧固件(Part of fixation in common use)1．螺栓 Bolt2．螺丝 Screw3．螺母 Nut4．方头螺栓 Sq head bolt5．埋头螺栓 Counter sunk head screw6．套筒螺栓 Socket head bolt7．定位螺栓 Set screw8．十字接头 Cross9．锥形销 Taper pin10．锁紧螺母 Lock nut11．六角头螺栓 Hex head bolt十、常用油类(Oil in common use)1．汽油 Gas oil2．煤油 Kerosene3．润滑油 Lubricating oil4．汽缸油 Cylinder oil5．压缩机油 Compressor oil6．齿轮油 Gear oil7．机油 Motor oil8．凡士林 Vaseline9．燃油 Fuel oil10．油脂 Grease11．柴油 Diesel oil十一、常用量词(Quantifier in common use) 1．件，只，个 Piece2．条，张，片 Sheet3．双 Pair4．套，组，副 Set.5．盒 Box6．箱 Case7．瓶 Bottle8．米 Meter9．厘米 Centimeter10．毫米 Millimeter11．公斤 Kilogram12．克 Gram13．公升 Liter14．平方 Square15．袋 Bag16．码 Yard17．吨 Ton18．磅 Pound19．加仑 Gallon20．立方 Cubic十二、国家名称(Name of country)1．中国 China2．美国 American3．日本 Japan4．英国 Britain5．法国 France6．德国 German7．韩国 South Korea8．希腊 Greece9．泰国 Thailand10．印度 India11．挪威 Norway12．俄罗斯 Russia13．新加坡 Singapore14．澳大利亚 Australia15．伊朗 Iran16．丹麦 Denmark17．加拿大 Canada18．丹麦 Denmark19．芬兰 Finland20．巴基斯坦 Pakistan21．意大利 Italy十三、常用缩语(abbreviation in common use)1．主机 M/E2．付机 A/E3．阀 V/V4．泵 P/P5．备车 St/by6．完车 F.W.E.7．前进三 FAHD8．微速后退 D.S.Ast9．前进二 H.Ahd10．高压 H.P.11．低压 L.P.12．重油/柴油 H.O./D.O.13．前后 F/A14．左舷 P: port15．无人机舱 UMS16．自动 Auto17．气缸 Cyl18．燃油柜 19．滑油柜 20．沉淀柜 .21．排出 Disc22．吸入 Suct23．柴油柜 十四、船用动态常用单词(marine tends word) 1．停靠 Alongside2．接近 Approach3．停泊 Berth4．浮筒 Buoy5．码头 Pier6．港口 Port7．移泊 Shift8．航次 Voyage9．试验 Try10．值班 Watch11．航行 Sail十五、船舶机电设备操作词汇(manipulate of marine equipment) 1．调整 Adjust2．压载 Ballast3．转换 Change over4．清洁 Clean5．联接 Connect6．排放压载 Deballast7．放残水 Drain8．卸载 Off9．油漆 Paint10．接通 Put on11．吹灰 Soot blown12．开始 Start13．顶端 Top14．洗 Wash15．吹 Blow16．检查 Check17．铲 Chip18．断开 Cut out19．排放 Discharge20．除垢 Descale21．检验 Examine22．受载 On(load)23．用泵排出 Pump out24．调整 Set25．停止 Stop26．调驳 Transfer27．加满 Top up十六、故障常用单词(words about malfunction)1．失常的 Abnormal2．烧坏 Burn3．堵塞 Clog4．裂缝 Crack5．变形 Deform6．毁坏 Destroy7．磨损 Wear8．出故障 In trouble9．敲击 Knock10．松开 Loose11．不对中 Misalign12．不足的 Insufficient13．失灵 Out of order14．过载 Overload15．过度磨损 Overworn16．尺寸过大 Oversized17．尺寸过小 Undersized18．振动 Vibrate19．不平的 Uneven20．不准确 Inaccurate21．全船断电 Black out22．出故障 Fail23．关掉 Shut off24．弯曲 Bend25．停车 Break drown26．腐蚀 Corrode27．腐蚀的 Corrosive28．损坏 Damage29．有毛病的 Faulty30．有缺陷的 Defective31．破裂 Fracture32．卡住 Jam33．漏泄 Leak34．漏泄的 Leaky35．融化 Melt36．噪声 Noise37．过热 Overheat38．咬住 Seize39．紧的 Tight40．松的 Loosen41．发现 Find42．停止 Stop43．脏的 Dirty44．油污的 greasy45．失效的 ineffective46．椭圆形的 oval47．点不着火 misfire48．接错 misjoin49．放错 misplace50．老化 perish51．麻点 pit52．凸起 ridge53．划伤 score54．拉痕 scuff十七、保养检修常用词汇(Words about maintain and examination) 1．卡死 Blind2．用卡钳量 Caliper3．关闭 Close4．解体 Disassemble5．安装 Fix6．组装 Box up7．检验 Check8．拆卸 Dismantle9．装配 Fit10．紧固 Fasten11．测量 Gauge12．安装 Install13．测量 Measure14．打开 Open15．上油漆 Paint16．换新 Renew17．上紧 Tighten18．洗 Wash19．涂油脂 Grease20．松开 Loosen21．加油 Oil22．检修 Overhaul23．重新组装 Reassemble 24．测取读数 Take reading 25．拧开螺栓 Unbolt26．抽出 Withdraw十九、时间、季节与方向(Time、Season and Direction) 1．星期一 Monday2．星期二 Tuesday3．星期三 Wednesday4．星期四 Thursday5．星期五 Friday6．星期六 Saturday7．星期日 Sunday8．春季 Spring9．夏季 Summer10．秋季 Autumn11．冬季 Winter12．一月 January13．二月 February14．三月 March15．四月 April16．五月 May17．六月 June18．七月 July19．八月 August20．九月 September21．十月 October22．十一月 November23．十二月 December24．小时 Hour25．分钟 Minute26．秒 Second27．月 Month28．天 Day29．夜 Night30．周 Week31．早晨、上午 Morning32．下午 Afternoon33．傍晚 Evening34．正午 Noon35．今天 Today36．昨天 Yesterday37．明天 Tomorrow38．前天 The day before yesterday 39．后天 The day after tomorrow40．本周 This week41．上周 Last week42．下周 Next week43．九月十日 Sep.10 th44．去年 Last year45．明年 Next year46．上周二 Last Tuesday47．下周一 Next Monday48．东 East49．西 West50．南 South51．北 North52．西北 Northwest53．东北 Northeast54．东南 Southeast55．西南 Southwest56．世纪 Century二十、常用词组（Phrases in common use）1 已无法修复 beyond repair2．尺寸过大 oversized3．反应缓慢 slow function4．不正常 out of order5 不合标准 not up to standard6．不准确 inaccurate7．失去作用 out of function8．轧住 seized9．过热 overheated10 过度磨损 ound excessive wear 11．过度磨掉 worn out12．有一点倾斜 a little bit inclined 13．不正常 abnormal14．因过热而损坏 founDestroyed by overheating15．龟裂 chapped16．塌陷 collapsed17．运转失灵 out of operation18．呈椭圆形 oval19．拉痕 scored20．拉毛 scuffed21．变形 deformed22．松动 loose23．油污 greasy24．肮脏 dirty25．咬住 stuck26．挤压 squeezed27．弯曲 bent28．故障 faulty29．损坏 damaged30．破碎成片 broken to pieces31．部分剥离 partly detached32．部分堵塞 partly choked33．剧烈震动 violent vibration 34．烧坏 burnt35．断裂 fractured36．接地 earthed37．敲缸 knocking38．溶化 melted away39．发现泄漏 leaking ( leaky) 40．冻结 stuck fast by icing41．锈蚀 rusty42．失效 ineffective43．故障 out of order44．结霜 frosted45．丢失 lost46．出故障 in trouble47．失灵 out of order48．失灵 out of action49．不一致 out of operation50．错位 out of place二十一、常用动词和例句(Verb in common use and example)1．借 borrow我要向你借这份图纸I want to borrow the drawing from you.我可以向你借这个手锤吗?May I borrow the hammer from you?2．裂 break阀杆断裂了The valve spindle is broken.滚动轴承断裂成碎片了The ball bearing are broken to pieces.3．加强 build up叶轮应该堆焊 The impeller should be built upby welding.4．烧 burn电动机烧了 The motor is burnt.5．进行 carry out应进行负载试验The load test should be carried out.6．吹 blow管子必须用压缩空气吹清The pipe should be blown with compressed air. 7．铸 cast按原样铸造一个 Cast one piece as per sample. 8．引起 cause损坏是有剧烈振动引起的The damage was caused by violent vibration. 9．倒角 chamfer油槽须倒角 Oil groove is to be chamfered.法兰切削后须倒角The flange should be chamfered after being machined.10．换掉 change把它们换掉,否则我拒绝验收Have them changed, otherwise I refuse to accept them.11．龟裂 chap轴瓦上的白合金龟裂了 The white metal onthe bearing bush is chapped.12．核查 check用桥规核查主轴承 Check the main bearingwith bridge gauge.修理前后要核查拐档差Check the crankshaft deflection before andafter repair.13．清洁 clean装前须清洁 Clean it before fit back.14．阻塞 clog燃油滤器阻塞了 The fuel filter is clogged.15．涂漆 coat用红丹涂管子 Coat the pipe with red lead.泵壳里涂防护漆The pump casing is to be coated with antifouling. 16．完成 complete finish你什么时候能完成修理工作?When can you complete (finish) the repair job? 17．连接 connect把电动机和淡水泵连接起来 Connect the motorwith the fresh water pump18．腐蚀 corrode泵壳和叶轮均有腐蚀 The pump casing andimpeller are corroded.19．盖 cover请把所有卸下的部件盖起来Please cover all the removed parts.20．裂二号缸头裂开穿透至冷却水空间No.2 cylinder head is cracked.21．吊 crane把液压马达吊上岸去修理Crane the hydraulic motor ashore for repair. 22．割 cut把底座割掉Cut off the bedplate.23．损坏 damage滚动轴承严重损坏The ball bearings are seriously damaged.24．脱落 detach白合金部分脱落了The white metal is partly detached.25．查看 detect查看氟里昂系统有无泄漏Detect the Freon system for leakage.26．解体 disassemble解体,清洁并检查高压油泵Disassemble, clean and check the H.P. fuel pump. 27．脱开 disconnect把起动空气管脱开Disconnect the starting air pipe.将发电机与原动机脱开。
轮机英语 Marine Engineering English
轮机英语- 轮机工程原理（英文版）Principles of Marine Engineering2010. 10ContentsContents (2)1 Main propulsion plant (篇标题) (3)1.1 Ships and machinery (章标题) (3)1.2 Diesel engine (9)1.3 Shaft and propellers (46)2 Marine auxiliary machinery (55)2.1 boilers (55)2.2 Pumps (55)2.3 Refrigeration, air conditioning and ventilation (55)2.4 Pollution prevention devices (55)2.5 Centrifugal separator and fresh water generator (55)2.6 Deck machinery (55)3 Electrical equipment and automatic control (56)3.1 Alternating current generators (56)3.2 Main switchboard and distribution system (56)3.3 Marine electrical equipment (56)3.4 Marine automatic control (56)4 Watch keeping and equipment operation (57)4.1 operation procedures (57)4.2 Safety operation (57)4.3 Stores and spare parts (57)4.4 Shipp repair and docking (57)4.5 Pollution prevention operation and Port State Control (57)5 International conventions and regulations (58)5.1 STCW (58)5.2 MAPROL (58)5.3 SOLAS (58)5.4 ISM (58)5.5 ISPS (58)6 Marine business writing (59)6.1 Engine log book (59)6.2 Repair list (59)6.3 Store order and spare parts requisition form (59)6.4 Accident report (59)6.5 Engineer’s reports, letters, faxes and emails (59)Index ............................................................................................................... 错误！未定义书签。
轮机英语(精编文档)
轮机英语（精编文档）一、轮机英语基础知识1. 轮机专业词汇（1）主机（Main Engine）（2）辅机（Auxiliary Engine）（3）冷却水（Cooling Water）（4）滑油（Lubricating Oil）（5）燃油（Fuel Oil）（6）螺旋桨（Propeller）（7）轴承（Bearing）（8）齿轮（Gear）（9）涡轮增压器（Turbocharger）2. 轮机英语常用句型（1）The main engine is running smoothly.（主机运行平稳。
）（2）Please check the cooling water temperature.（请检查冷却水温度。
）（3）The lubricating oil level is too low.（滑油液位过低。
）（4）We need to replace the fuel filter.（我们需要更换燃油滤清器。
）（5）The propeller is damaged and needs repair.（螺旋桨损坏，需要修理。
）3. 轮机英语阅读材料（1）船舶柴油机说明书（2）轮机维护保养手册（3）轮机故障分析与处理案例（4）国际海事组织（IMO）相关法规二、轮机英语沟通技巧1. 听力训练（1）多听英语广播、新闻和轮机相关讲座。
（2）观看轮机英语教学视频，学习专业词汇和句型。
（3）在船上实习时，积极参与轮机部门的日常工作，提高实际听力水平。
2. 口语表达（1）模仿英语发音，练习标准发音。
（2）参加英语角或轮机英语培训班，与同学进行交流。
（3）在船上实习时，大胆与外籍船员交流，提高口语水平。
3. 书面表达（2）阅读并分析轮机英语范文，掌握写作技巧。
三、轮机英语实际应用场景1. 船上日常沟通（1）交接班时，向同事详细描述设备运行状况和需要注意的问题。
（2）在紧急情况下，准确传达指令，如：“Emergency stop! Close the fuel valve immediately!”（紧急停止！立即关闭燃油阀！）（3）与船长、大副等高级船员讨论船舶维护和修理计划。
《轮机英语听力与会话(轮机长)》课程标准
《轮机英语听力与会话（轮机长）》课程标准【课程名称】轮机英语听力与会话【英文名称】Marine Engineering English Listening and Speaking【课程类型】必修课、职业能力素质课【适用专业】轮机工程技术【总学时】70 学时（理论学时：66 机动学时：4）【前导课程】《大学英语阅读》、《大学英语听力》、《大学英语口语》1．课程性质轮机英语听力与会话是轮机工程技术专业学生的重要专业课之一。
学生在经过基础英语阶段的学习以后，通过本课程的学习，能够听懂并理解轮机工程专业所涉及的英文内容，掌握中心大意，理解其中重要关键信息；并且能够进行有效的面对面的口语沟通和交流。
发音基本准确，语言基本流畅，表意基本完整。
使学生达到教学计划中本课程所涉及的知识、能力与素质要求，基本掌握能够履行船舶轮机长职责足够的专业英语知识，满足《1978年海员培训，发证和值班标准国际公约》和95年修正案（简称STCW78/95公约）要求。
2．设计思路1）以职业能力培养为导向，开展练中学、练中教，教、学、练结合，理论讲授与语言应用练习交替互动的教学模式。
2）以课程目标和船舶轮机长岗位的真实工作任务作为选择课程内容的标准。
3）以高职学生的认知规律和职业技能培养目标作为课程内容模块化的依据来序化教学内容。
4）优化教学设计，充分利用教学资源，提高学生专业英语适岗适任能力，培养学生职业英语综合素质。
3．课程目标3.1 知识目标通过学习，使学生了解和掌握以下内容的专业英语：I。
公共用语1）日常用语2）日常对外业务用语3）船东面试时用语II。
机舱日常业务1）主机系统①轮机设备部件名称②主机燃油系统操作与管理③主机冷却水系统操作与管理④主机润滑油系统操作与管理⑤主机起动空气系统操作与管理⑥主机运行工况监测⑦主机换气、增压系统操作与管理⑧主机故障排除⑨主机维护保养⑩主机智能设备操作2）辅助设备①锅炉的操作与管理①发电柴油机的操作与管理①空调和制冷系统的操作与管理①空压机的操作与管理①造水机的操作与管理①分油机的操作与管理①油水分离器的操作与管理①焚烧炉的操作与管理①生活污水处理装置的操作与管理①舵机的操作与管理①压载水系统操作与管理①舱底水系统操作与管理①甲板机械的维护与管理①电气设备的操作与管理①电气设备的安全注意事项①消防水系统的操作与管理①生活日用水系统的操作与管理III。
轮机英语口语
unit 1
介绍
2
unit 1
接收文件
3
Unt 1
介绍及接收文件
5
Unit 1
接收主机
6
Unit 1
接收物料及备件
7
Unit 1
接收舵机
8
Unit 1
接收应急设备
9
Unit 1
接收副机
10
Unit 1
并车操作
11
Unit 1
接收分油机
12
Unit 1
谈论海水淡化装置
13
Unit 1
谈论辅机
39
Unit 5
检查
40
Unit 5
关于锅炉
41
Unit 5
关于污水
42
Unit 5
常用语句
43
Unit 6
接到通知
44
Unit 6
机舱内操作
45 Unit 操作
46 Unit 清洁工作
47 Unit 常用语句
61 Unit8 讨价还价 62 Unit8 专门订货 63 Unit8 验收 64 Unit8 退货 65 Unit8 付账 66 Unit8 常用语句 67 Unit9 与船长磋商 68 Unit9 轮机员的碰头会1 69 Unit9 轮机员的碰头会2 70 Unit9 核对修理单 71 Unit9 一般交流 72 Unit9 常用语句
订备件 讨论订单
轮机英语 口语
轮机英语 口语
18 Unit 落实准备工作
19 Unit 主机暖机
20 Unit 关于副机
21 Unit 关于海水淡化装置
22 Unit 常用语句
23 Unit 对时与对车钟
《轮机英语》课程标准
《轮机英语》课程标准一、课程信息考试考查□是是二、课程性质与作用《轮机英语》是轮机工程技术专业的一门重要的专业技术课程，旨在为学生掌握必需的专业语言技能、适应日后工作奠定坚实的理论和实践基础。
通过本课程的学习，使学生初步具备五个方面的能力：船舶主推进装置专业语言技能、船舶辅机专业语言技能；船舶电气及自动化专业语言技能；船舶管理及国际公约语言技能。
结合课程教学，培养学生的语言能力以及学习新技术的能力。
本课程在培养高素质技能型轮机工程技术人才方面起着综合提高的作用，对学生的职业能力培养和职业素养的养成起着支撑或促进作用。
本门课程作为船舶轮机员（三管轮）的适任考证课程，其前导课程是《船舶柴油机》、《船舶辅机》、《船舶电气及自动化》、《船舶管理》等专业课程。
表2 课程功能定位分析通过本课程的学习，能使学生进一步增强民族复兴责任感和自豪感，增强爱国、爱党的意识；树立社会主义核心价值观；弘扬精益求精的工匠精神，增强对国家海洋强国战略的使命感；为我国的航运强国以及一带一路的战略实施尽到自己的职责。
并养成较强的集体意识和团队合作精神，能够进行有效的人际沟通和交流，具有较强的专业创新能力和素养，为日后适任工作岗位、进一步学习和研究打下良好的基础。
四、课程目标本课程通过大量远洋、海运公司的第一线专业调研和专家、学者和教师组成的专家队伍论证，形成从专业定位、课程内容组织、教学活动设计到课程体系构建链条。
即：贯彻以职业生涯发展为目标——明确专业定位，以职业能力为依据——组织课程内容，以船舶机舱设备自动控制的真实场景为载体——设计教学活动，以职业技能鉴定为参照——强化技能训练，以工作任务为线索——构建基于工作过程的课程体系。
本课程的任务是在公共英语和轮机基础英语教学的基础上，巩固、扩大学生的英语基础，培养学生阅读和翻译简明轮机英语出版物和有关技术资料的能力和书写与本专业有关的简短文书的能力，使学生能以英语为工具，进行业务交流，在理论上达到STCW公约中规定的管理级船员应具备的英语水平，在实践技能上达到操作级船员应具备的英语水平。
轮机英语听力与会话
Listening and Spoken English for Marine Engineers
三、对话
New words： 1. bother 麻烦、烦恼 2. fail 【教育学】没有通过…的考试 systematically [sistə'mætikəli] 有系统地,有组织地,有 条理地 3. quit smoking 戒烟 4. feel terrible 感觉很糟糕； ashtray 烟灰缸 5. apologize for 因…道歉； worry about 焦虑…；担 心… infer from 从…推断(或推论) 6. promote 提拔、提升
Listening and Spoken English for Marine Engineers
42. leave a message for 给 ... 留口信 43. subtitle 说明字幕 47. fare 票价 53. change 找回的零钱; tip 小费 55. on schedule准时，按时间表 59. so long 再见 60. cooperative attitude 合作态度； 61. register of shipping 船舶登记局 64. Lloyd's register 英国劳埃德船级社 66. consult with 商量、协商；consultant 顾问； talk over 商量
Listening and Spoken English for Marine Engineers
7. appreciate 为…表示感激(或感谢) 8. sprain one's ankle 扭伤脚踝； miserable 痛苦的 10. gratitude 致谢、感谢、感激 15. flight 航班、班机 17. heart and soul 全心全意地、满腔热情地； halfheartedly 不认真地 19. for ages 很久；很长时间，多年； attitude 态度； theater 电影院 21. president董事长； 瑞士苏尔寿公司（SULZER）是传质和分离技术的领导者， 在世界范围内为客户提供先进和完整的分离和混合技术。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
The watertube boiler does
however require greater skill in operating and maintaining ， especially with regard to the purity of the feed water, and its upkeep (维修费) is more costly than the firetube boiler.
Lesson 16
Marine boilers
Jimei university
There are two distinct types of marine boilers in use on board ship,
Jimei university
the fire-tube boiler(烟管锅炉、
Jimei university
Jimei university
The furnace is at the side of the two drums and is surrounded on all sides by walls of tubes.
auxiliary purposes to provide smaller quantities of low pressure steam on diesel engine powered ships.
Jimei university
Firetube boilers were commonly used with steam reciprocating engines on board ship, but because of their comparative poor efficiency and low power/weight
Jimei university
A later development of watertube boilers is the bent tube design.
Jimei university
This boiler has two drums, an integral furnace and is often referred to as the ‘D’ type because of its shape.
火管锅炉) in which the hot
gases from the furnaces pass through the tubes while the water is on the outside,
Jimei university
and the water-tube boiler(水管
锅炉) in which the water flows
resulting
in
mechanical
straining(机械变形).
Jimei university
(ii) The steam and water drums( 锅 筒 ) are small in diameter compared with the large
shell(锅壳) of the firetube boilers,
Jimei university
Water tube boilers have
distinct advantages over
firetube boilers.
Jimei university
(i) Circulation of the water is natural and immediate on lighting up, thus steam can be raised from cold water in a shorter period of time without
therefore they are stronger and suitable for much higher steam pressure.
Jimei university
(iii) Less mass of water is
carried in the boiler, hence a
saving in weight and less space is taken up for the same output.
through the inside of the tubes while the hot furnace gases pass around the outside.
Jimei university
The water-tube boiler is
employed for high pressure, high
ratio(功率重量比), these systems
are no longer installed for propulsion plant.
Jimei university
There are many types of watertube boilers in general use on board ship and each manufacturer has a variety of designs to offer depending upon requirements.
temperature, high capacity steam
applications, e.g. providing steam
for main propulsion turbines or cargo pump(货油泵) turbines.
Jimei university
Fire-tube boilers are used for
Jimei university
without the danger experienced
in firetube boilers having larger
பைடு நூலகம்
temperature differences between
top and bottom parts of the boiler
causing unequal expansion