苏泊尔SJ207A-700榨汁机使用说明书
果汁制造设备操作规程汇编
果汁制造设备操作规程汇编（一）洗检果机操作规程一、开车前准备1、检查所有设备和管道应是清洁的。
2、检查设备和管道连接是否正确。
3、检查洗检果机链条、齿轮部分防护罩应安装完好。
二、开车按顺序启动洗果机、检果机、输送机、提升机，并开启洗果机的供水，为下一步压榨机的开启作好准备。
三、注意事项洗检果机维修时，电器控制盘一定要悬挂有人工作，禁止合闸的牌子，任何人不得随便开机。
（二）履带榨机操作规程一、开机1、启动空压机，检查压缩空气供给是否正常，空气压力不低于6公斤。
2、启动履带榨机的无级变速电机，使履带榨机处于正常运转状态。
调节上、下带压力在5公斤，调节压榨滚子压力2.5－3公斤，调节履带防偏压力3公斤。
3、开启高压喷淋水泵。
4、开启振动筛。
5、按顺序启动洗果机、检果机、提升机、果仓和浆料泵，使履带榨机进入榨汁工作状态。
6、启动振动筛出料泵，将料打入收集罐。
7、启动浆料泵螺杆泵，使榨机处于正常运转。
8、调节料厚均匀，使带速与螺杆泵转速相谐和。
二、停车1、将送果系统及果仓，浆料泵停机。
2、高压喷淋水泵停机。
3、履带榨机无级变速电机停机。
4、空压机停机。
5、振动筛及打料泵停机。
三、清洗操作：1、机未开时，先进行人工清洗，将履带榨机整个系统、接料盘的杂质刷洗干净。
2、启动履带榨机的无级变速电机，使之处于运转状态。
3、开启高压喷淋水泵，用清水喷淋10分钟。
（三）反渗透操作规程一、开机1、检查加药箱药剂是否充足。
2、检查各阀门开启是负正常。
3、开启原水泵排气阀门，待原水流出后，关闭排气阀门，启动原水泵。
4、打开精密过滤器排气阀门，待水流出后，关闭排水阀门，启动高压泵，依次开启1、2、3、号计量泵。
5、待水罐液位充足后，启动离心泵，使处理过的水进行二次处理后进入纯水罐。
二、清洗1、砂滤器用自来水正冲10分钟，反冲10分钟。
频率为1次/3天。
2、反渗透每半个月用15Kg柠檬酸清洗。
（四）树脂操作规程一、开机1、检查所有设备和管道应是清洁的。
榨汁机说明书
榨汁机使用方法以及配方大全（组图）2008-09-27 来源：中华橱柜网整理现有网友评论 0 条进入论坛榨汁机很容易保证水果的数量和品种，可以同时将几种水果放在一起，根据个人的口味榨出自己喜欢的果汁或果蔬汁饮用，绝对会让你“食”指大动哦。
不过，现在也有很多朋友家里并没有榨汁机，而面对卖场里琳琅满目、功能各异的榨汁机，又不知道该如何挑选，不妨注意以下几点：1、外观：造型美观大方，表面光泽，四周无利角锋边，投放原料安全方便。
2、榨汁效果是衡量榨汁机质量好坏的重要因素，好的榨汁机应该榨汁干净彻底，果渣中所含的水分少。
3、渣滓储藏格：是专门存放果渣的容器，分离式渣滓储藏格可在榨汁过程中停止工作以清除果渣，使用更方便。
4、电源线储藏格：带有电源线储藏格的榨汁机容易收藏，其不易损坏电源线。
5、安全装置：榨汁机一般都设有安全锁定装置，在附件未安装到位时，机器不能工作，选购时在附件未安装情况下小心启动电源，检查机器是否配安全锁定装置。
橘子甜汁用料：橘子3个，胡萝卜一根。
做法：胡萝卜洗净，去头尾，切成长条，放入榨汁机中榨纯汁待用。
橘子去皮，剥成小瓣，放入榨汁机中榨汁。
两种果汁搅拌均匀后即可饮用。
柑橘类水果含有丰富的维生素c，对于美白有明显效果，是绝佳的美容圣品。
但是最好在晚上饮用，以避免柑橘类的光敏作用。
准备材料的时候不要去掉橘瓣上白色纤维丝，否则就不能摄取到可降低胆固醇的果胶。
玫瑰果茶用料：新鲜西芹1支，干燥玫瑰花若干朵，柳橙1个，蜂蜜1大匙。
做法：柳橙洗净对切，去皮榨汁，待用。
西芹洗净切段，在开水中略烫，榨汁，倒入柳橙汁中搅拌。
干玫瑰花用温水泡开，撒在果汁中。
再加入蜂蜜即可饮用。
玫瑰花性温微酸，可使肌肤润泽美白，增进血液循环，消除紧张疲劳。
这道茶可作为饭后饮料，帮助消化吸收，促进气血健康。
猕猴桃菠萝汁用料：猕猴桃1个，菠萝100克，冰块若干，冷开水50毫升。
做法：菠萝切块榨汁，待用。
猕猴桃对开切，用汤匙挖出果肉，放入榨汁机中，加入菠萝汁、冷开水、冰块快速打匀，即可饮用。
苏泊尔搅拌机-真空随行果汁机使用说明书(型号BV501-300)
5
安全注意事项
当您使用本产品时，特别提醒注意以下内容： 本机切勿让儿童、行动不便者、精神上有障碍或不会使用的人独 自操作；老年人和残障人士应该在监护和指导下使用。 请放置于儿童触摸不到的地方使用和保管；并告知儿童本产品不 能用于玩耍。 本机使用交流220V/50Hz的电源，使用前请确认家中电压是否相 符合。 将本机置于平稳、耐热的表面上使用。严禁放在潮湿或靠近火源、 热源（如炉具）的地方，以免意外引燃导致火灾或产品损坏。 使用前请先检查电源线、密封圈、刀片等部件有无损坏，如有损 坏，请停止使用，并与公司客服人员联系解决。 拔插头时请捏住插头拔下，不能拉拽电源线；不可湿手去拔、插 电源插头，以免导致触电。 电源线插头必须保持干净、干燥状态；勿将电源线过度弯曲、捆 绑或放置于高温附近、重物挤压或挂于锋利的物体上，否则可能 使电源线破损而引起火灾、触电。 如果电源软线损坏，为了避免危险，必须由制造商、其维修部或 类似部门的专业人员来更换。 本机在进行组装、拆卸或清洗前，请确保断开电源。 本机在接通电源后，即使是很短时间内，也要确保有人看管，特 别是当有儿童在场时。 在使用本机时，请勿将长发、围巾或领带等悬垂于机器之上。 请勿使用较硬食物（如坚果）或含纤维食物（如甘蔗），以及非 食物的其它物体，以免损坏机器。 6
顾客服务部联系方式： 地址：浙江省杭州市高新技术产业区滨安路501号 邮编：310052 全国服务热线：400-8899-717 网址： 服务网点联系方式：敬请拨打全国服务热线400-8899-717；
或登陆苏泊尔网站查询。
10
环保清单
2 将刀座组件刀片朝下放入随行杯上，并顺时针拧紧， 构成搅拌杯组件。 安装刀座组件前，请确保密封圈正确安装在刀座上。 刀片锋利，安装时请小心伤手！
榨汁机用户手册说明书
JuicerNUser's manual ESJE 741BKSJE 742RDSJE 743WHPrior to using this appliance, please read the user's manual thoroughly, even in cases, when one has already familiarised themselves with previous use of similar types of appliances. Only use the appliancein the manner described in this user's manual. Keep this user's manual in a safe place where it can be easily retrieved for future use.We recommend saving the original cardboard box, packaging material, purchase receipt and responsibility statement of the vendor and warranty card for at least the duration of the legal liabilityfor unsatisfactory performance or quality. In the event of transportation, we recommend that you packthe appliance in the original box from the manufacturer.E N Juicer SJE 741BK / SJE 742RD / SJE 743WH TABLE OF CONTENTSIMPORTANT SAFETY NOTICE (3)DESCRIPTION OF THE JUICER (5)BEFORE FIRST USE (6)ASSEMBLING THE JUICER (6)USING THE JUICER (6)USEFUL TIPS (7)RECIPES (8)CLEANING AND MAINTENANCE (9)TECHNICAL SPECIFICATIONS ............................................................9INSTRUCTIONS AND INFORMATION REGARDING THE DISPOSAL OF USED PACKAGING MATERIALS .10DISPOSAL OF USED ELECTRICAL AND ELECTRONIC EQUIPMENT (10)JuicerNSJE 741BK / SJE 742RD / SJE 743WH E IMPORTANT SAFETY NOTICE1) Carefully unpack the appliance and take care not to throwaway any part of the packaging before you find all the partsof the appliance.2) This appliance may be used by persons with physical or mentalimpairments or by inexperienced persons, if they are properlysupervised or have been informed about how to use the productin a safe manner and understand the potential dangers.3) Children must not use this appliance or play with it. Keep theappliance and its power cord out of their reach.4) Never use accessories that have not been delivered with thisappliance or are not intended for it.5) Under no circumstances should you try to repair or adjust theappliance on your own - danger of electric shock! Entrust allrepairs and adjustments to a specialised company/service. Bytampering with the appliance you risk voiding your legal rightsarising from unsatisfactory performance or quality warranty.6) Only store and use the appliance away from flammable orvolatile materials and solutions.7) Keep the appliance away from extreme temperatures,direct sunlight and excessive humidity. Do not use in a dustyenvironment.8) Do not place the appliance near heaters, open fires or otherproducts or equipment that are sources of heat.9) This appliance is designed for household use. Do not use it inindustrial surroundings or outdoors!10) Do not use the product for purposes other than those intended.11) Before connecting the product to the power outlet ensure thatthe voltage on the rating label is the same as that in the poweroutlet.E N Juicer SJE 741BK / SJE 742RD / SJE 743WH 12) Do not place the power cord near hot places or sharp objects. Do not place heavy objects on the power cord. Position the power cord so that it will not be stepped on or tripped over. Make sure the power cord is not touching a hot surface.13) If the power cord of the product is damaged, have it repaired by an authorised service technician to prevent causing a dangerous situation. It is forbidden to use a product with a damaged power cord or plug.14) Do not disconnect the power cord from the wall outlet by pulling the cord.15) Do not use the juicer if the strainer is damaged.16) Never submerge the motor unit in water or any other liquid.17) Always turn off the appliance and disconnect it from the power socket if you will not be using it and if you are leaving it without supervision, before assembly, disassembly or cleaning.18) Prior to removing accessories or parts that move during use, check that the appliance is turned off and disconnected from the power socket and wait until the moving parts come to a stop.20) Do not insert your hands or foreign objects into the feed tube during operation.21) Do not push ingredients into the feed tube using your hands or any utensils. Always use the provided plunger.22) Be careful when handling the stainless steel strainer as the blade on the bottom is very sharp. Careless handling may result in injury.23) The manufacturer takes no responsibility for damages caused by the incorrect use of this product and its accessories (injuries, burns, scalding, fire, food spoilage, etc.).When the juicer is running, do not place fingers or anyother items (except for the juiced fruit and vegetables) into the feed tube.JuicerNSJE 741BK / SJE 742RD / SJE 743WH E DESCRIPTION OF THE JUICERE N Juicer SJE 741BK / SJE 742RD / SJE 743WH BEFORE FIRST USE1) Thoroughly wash all parts that are intended to come into contact with food using warm water and a neutral kitchen detergent. Then rinse with clean water and wipe dry.2) Place the juicer on a stable non-slip even surface.3) Connect the plug of the power cord to a suitable power socket (220-240 V).ASSEMBLING THE JUICER1) Insert the juice collector into the juicer as shown in the picture. Make sure that the juice collector spout is located in the cut-out in the base unit.2) Place the stainless steel strainer into the juice collector. Make sure that the strainer is firmly seated on the drive shaft. When seated correctly, the top edge of the strainer should be under the level of the top edge of the juice collector.3) Place the pulp container into the base unit. First move the top end and then push down the bottom end towards the juicer. Check that the pulp container is inserted correctly. When correctly seated, there should be a space of no more than 1 mm between the pulp container and the base unit.4) Cover everything with the lid and push it down into the correct position.5) Use one hand to push the lid downwards and at the same time tilt the safety latch on to it so that the lid is secured in the correct position. An audible click will be heard. The juicer is equipped with a safety mechanism that prevents it from being started unless the lid is correctly seated and secured in place with the safety arm.6) Now insert the plunger into the feed tube. Notice, that to make movement easier, the feed tube is equipped with a groove that fits together with the coupling in the top part of the feed tube.USING THE JUICER1) Slide the juice jug on to the spout.2) Get ready to process ingredients. Thoroughly wash all the ingredients before juicing them. After washing them, cut the ingredients into smaller pieces that will pass through the feed tube. Prior to juicing certain types of fruit and vegetables, it is necessary to first remove hard stones that are contained in, for example, apricots, peaches, mangoes, etc. and inedible peels, e.g. from oranges, pineapples, melons, mandarins, etc. You will find further processing tips in the section "Useful advice" (see below).3) Turn the control dial to position "1" or "2" depending on the type of fruit or vegetables being processed. For softer ingredients, use speed 1 (e.g. grapes, bilberries, melon, raspberries, tomatoes, etc.). For harder ingredients, use speed 2 (e.g. pineapple, celery, carrot, beet, apples, etc.).JuicerNSJE 741BK / SJE 742RD / SJE 743WH E4) Place the prepared ingredients piece by piece into the feed tube and using the plunger slowlypush them down on to the rotating stainless steel strainer. Do not exert excessive force. Juice the ingredients slowly to achieve the maximum possible yield.5) During the juicing process, the juice will go to the juice jug and the pulp is separated and collectedin the pulp container. You can empty out the pulp container while juicing, however, first turn the control dial to position "0" (off) and disconnect the power cord from the power socket. Then release the safety arm, remove the lid and carefully take out the container. Before continuing with the juicing process, put the empty pulp container back in its place and return the lid and lock the appliance with the safety arm. Then connect the power cord to the power socket and you can start the juicer again.Attention:This appliance is designed only for short term use. When juicing larger batches, do not use thisjuicer continuously for more than 60 seconds and always allow the juicer to cool down sufficientlybetween the individual runs for at least 60 seconds. After three juicing cycles, allow the applianceto cool down for at least 15 minutes.6) When you have finished using it, turn the juicer off, disconnect it from the power socket and cleanit out according to the instructions contained in the chapter Cleaning and maintenance.USEFUL TIPSBefore you start using the juicer, read the following tips which will help you achieve maximum juice yield, an optimal taste and also make your work easier:• Only use fresh and ripe fruit and vegetables as they contain more juice. The following types of fruit and vegetables are particularly suitable for juicing: pineapple, apple, orange, grapes, melons, cucumbers, carrot, celery, beetroot, tomatoes, etc. Do not juice unripe or overripe fruits and vegetables as they could negatively affect the taste of the juice.• With root vegetables (such as carrot or beetroot), always check before juicing that you have removed all soil, tops and leaves, and that you have washed everything thoroughly.• Fruits with large, hard seeds or stones (e.g. nectarines, peaches, mangoes, apricots, plums and cherries) must have their seeds or stones removed prior to juicing.• There is no need to remove edible peels (e.g. from apples, pears). It is only necessary to remove thick rinds (e.g. on oranges, pineapples). Furthermore, always also remove the white fibres in the centre of citrus fruits because they have a bitter taste.• When preparing apple juice, remember that its thickness depends on the type of apples that you are processing. The juicier the apple, the less thick the juice will be. Apple juice turns brown very quickly. You can slow down this process by adding a few drops of lemon juice.• This juicer is not suitable for processing leafy vegetables, herbs or fruits such as bananas, avocados, figs.• If you decide to store the juice in a refrigerator, do not leave it there for longer than a day. Freshly made juices quickly loses valuable vitamins.E N Juicer SJE 741BK / SJE 742RD / SJE 743WH RECIPESTomato juiceJuice 1 kg of fresh ripe tomatoes and serve immediately. To improve taste, add celery tops and fresh pepper.Apple juiceJuice 4 large apples and serve immediately. You can combine various types of apples. To achieve a sweeter taste and an increased vitamin content, add a carrot.Island cocktailJuice 1 medium-sized pineapple, 1 papaya, 1 large orange and 1 guava. Add 1 mango (process in a mixer). Serve immediately.Carrot fruit juiceJuice 4 large carrots together with 2 sweet apples. Serve immediately.Pineapple juiceJuice 4 pineapple slices, 1 medium-sized orange and serve immediately.JuicerSJE 741BK / SJE 742RD / SJE 743WHE N CLEANING AND MAINTENANCE•Before cleaning it, always make sure that the juicer is turned off and disconnected from the power socket.• First remove all removable parts that come into contact with food (plunger, lid with the feed tube,stainless steel strainer, juice collector, pulp container, juice jug) from the juicer.Attention:Prior to disassembly, wait until the stainless steel strainer, that rotates while the juicer isrunning, comes to a stop.The blade on the bottom of the stainless steel strainer is very sharp and so it is necessary to be especially careful when handling it to prevent injury.•Clean the removable parts using warm water and neutral kitchen detergent. Then rinse them under clean running water and wipe dry.•To clean the base unit, use a cloth dipped in a weak detergent solution. Then wipe everything with a clean dampened cloth and wipe dry. •Never submerge the base unit or its power cord in water or any other liquids.• For cleaning, do not use thinners or solvents or cleaning agents causing abrasion. Otherwise thesurface of the appliance may be damaged.TECHNICAL SPECIFICATIONSRated voltage ................................................................................................................................220−240 V Rated frequency ................................................................................................................................50/60 Hz Rated power input ...............................................................................................................................400 W Safety class (with regard to electric shock protection) ...............................................................................II Pulp container capacity ...........................................................................................................................1.2 l Noise level .........................................................................................................................................85 dB(A)The declared noise emission level of the appliance is 85 dB(A), which represents a level A of acoustic power with respect to a reference acoustic power of 1 pW.Included contents:1x juicer1x pulp container1x juice jug with foam separator1x plunger1x lid with feed tube 1x stainless steel strainer 1x juice collector 1x user's manual 1x warranty cardChanges to text and technical parameters are reserved.E N Juicer SJE 741BK / SJE 742RD / SJE 743WH。
Philips HR1897 30 极速榨汁机用户手册说明书
Avance CollectionMicroMasticating technology Metallic GreyLED feedbackExtra filterHR1897/30Unleash all the goodness into your glass MicroMasticating extracts up to 90%* of the fruit Philips innovative MicroMasticating technology is designed to open up the cells of your fruits and vegetables to squeeze the maximum of your ingredients. After juicing all parts can be rinsed clean in 1 minute thanks to its no sieve design.Extract all the goodness from fruits and vegetableMicroMasticating extracts up to 90%* of the fruitJuice all your favorites, including bananas and mangosInclude leaves, greens and nuts in your drinksPre-clean function squeezes last drops of juice outA juicer you can finally rinse cleanEasily detachable and rinsed clean without any kitchen toolUnique no sieve design for cleaning in under 1 minuteInnovative drip stop keeps your counter cleanLED lights give you reassembly feedbackThoughtfully designed for your kitchenSlim juicer with all integrated partsJuice directly into your glassInspiring recipe book includedDetachable parts can be stored in the pulp containerHighlightsMicroMasticating technologyFruits and vegetables have many thousands of cells that contain juice, vitamins and other vital nutrients. Philips innovative MicroMasticating technology is designed to open up the cells to squeeze the maximum of your favoriteingredients and will help you to get up to 90%*of your fruits into the glass and not as waste.Soft fruits to hard vegetablesMake delicious healthy juices from soft fruits and hard vegetables. You can juice all your favorite combinations and use this products even for those especial starch ingredients that are normally very difficult to juice such as bananas or mangos.</Leaves, greens and nutsLeaves and greens full of fibers are also great ingredients for healthy juices and they can all be processed in this juicer. Wheatgrass,spinach and many others could be animportant health adder to your daily juices with MicroMasticating technology. You can even use certain kind of nuts, like the almond to prepare almond milk.Pre-clean functionThe pre-clean function is a special program that squeezes last drops of juice out of thejuicer while cleaning the inside of your product at the same time. This will help you to get the best from your fruits and vegetables and avoid that valuable juice goes to waste in the cleaning process.QuickClean in 1 minuteWith an easily detachable design and rimless parts, this juicer can be quickly cleaned using only tap water. Because there are no sharp edges, the fibers or particles of ingredients are rinsed away in seconds.No sieve designOur unique no sieve design allows the juice to flow seamlessly to your glass going through a filter that removes any unwanted part from the juice and is so easy to clean that you don’t need any brushes.Innovative drip stopFully integrated drip stop allows you to stop between juicing sessions and keep yourcounter top clean at all times. Simply push the bottom of the juice outlet and without wetting your fingers the juice flow will stop.LED feedbackLED gives you feedback when operating this juicer. After reassembling you will know when the product is ready to juice again of if you still need to place the parts in the right places.Everything with your safety in mind.IF DESIGN AWARDIF award-winning products and projects,concepts and more, selected by the top names in design.Each year, iF International Forum Design GmbH organizes one of the world's most celebrated and valued design competitions: the iF DESIGN AWARD.Recognized as a symbol of design excellence around the world, the iF DESIGN AWARD welcomes over 5,000 submissions from 70countries every year.SpecificationsAccessoriesIncluded: Filter, Jug, Recipe booklet General specificationsProduct features: Dishwasher safe, Non-slip feet, On/off switch, Safety lock, Quickclean DesignColor: Metallic Black FinishingMaterial accessories: Metal safety lockMaterial jar: PlasticMaterial of main body: PlasticMaterial waste container: PlasticService2-year worldwide guaranteeTechnical specificationsCapacity jar: 1 LCapacity pulp container: 1 LCord length: 1 mFrequency: 50-60 HzPower: 200 WVoltage: 220-240 VRPM: 300 RPMSustainabilityPackaging: > 90% recycled materialsUser manual: 100% recycled paperCountry of originMade in: China* Internal tests on 1000g each of grapes, apple, blackberry, strawberry, tomato, watermelon, orange andpomegranate.© 2020 Koninklijke Philips N.V.All Rights reserved.Specifications are subject to change without notice. Trademarks are the property of Koninklijke Philips N.V. or their respective owners.Issue date 2020‑10‑29 Version: 5.1.1。
榨汁机
榨汁机
我不喜欢吃水果，也不喜欢吃菜，爸爸妈妈就给我买了个榨汁机。
榨汁机由推杆、水果托盘、上盖、安全扣、开关、马达基座组成。
我对照说明书慢慢组装榨汁机：先在马达基座上放入果汁碗，再在果汁碗中间装上过滤器，接着把上盖盖上，然后把安全扣扣好，最后将水果托盘反扣于上盖的进口处，这样榨汁机就组装好了。
接着，妈妈把水果洗干净，削了皮，切成小块，我把水果块放入水果托盘中，用推杆将水果压入进料管内，果汁就从导液口缓缓地流到杯子里。
榨汁机榨出的是甜甜的果汁，但里面包含的却是爸爸妈妈的爱心和关心。
其实，生活中，爸爸妈妈对我的关爱是无处不在的。
苏泊尔小榨汁机的用法
苏泊尔小榨汁机的用法
苏泊尔小榨汁机的用法如下：
1. 准备食材：选择新鲜的水果或蔬菜，如苹果、橙子、胡萝卜等。
清洗食材并削皮或去核。
2. 组装机器：将榨汁机的大容器放在底座上，确保锁定好。
将切割盘或刀片安装在容器内。
3. 加入食材：将切割好的食材放入容器内，并将盖子盖好。
4. 开始榨汁：接通电源，按下开关启动榨汁机。
根据食材的硬度和纤维程度选择合适的转速。
通常一般的水果和蔬菜使用低速，坚硬的食材则可选择高速。
5. 收集果汁：果汁会从出汁口流出，使用提供的杯子接收果汁。
为了提高果汁的口感和质量，可以使用提供的滤网去除果渣。
6. 清洁保养：使用完成后，断电并拔掉电源插头。
将榨汁机的各个零部件拆卸下来清洗，避免残留物附着。
注意刀片较为锋利，需小心操作。
以上就是苏泊尔小榨汁机的基本用法。
在使用时，还需详细阅读说明书，并根据个人需求选择合适的榨汁方式和食材。
家庭用果蔬榨汁机设计说明书
目录摘要 (2)Abstract (3)第一章绪论 (4)1.1 论文概述 (4)1.2 选题背景 (4)1.3 榨汁机国内外发展现状 (5)1.3 本文研究内容 (7)第二章榨汁机原理介绍 (9)2.1 榨汁机分类 (9)2.2 家庭用离心式果蔬榨汁机原理 (11)2.3 榨汁机使用注意事项 (13)2.4 本章小结 (13)第三章榨汁机机构设计 (14)3.1 榨汁机选购方法 (14)3.2 载荷受力分析 (14)3.3 齿轮设计 (17)3.4、电机选型计算 (22)3.5、轴的设计 (23)3.6、螺栓校核计算 (28)第四章果蔬榨汁机三维建模 (31)4.1 SolidWorks三维建模技术 (31)4.2 果蔬榨汁机三维建模 (31)4.3果蔬机装配 (46)4.4 本章小结 (50)参考文献 (51)致谢 (52)摘要随着现代生活步伐的加快，健康问题已经成为了人们关注的焦点，各种健康知识更是成为了茶余饭后的话题，其中鲜果汁更是被越来越多人所了解。
每天早晨喝一杯鲜果汁或蔬菜果汁，有增加活力及稳定血压等功效，特别是老人小孩，单单吃水果既不容易消化，更不容易吸收。
几乎所有蔬菜果汁皆有帮助排便的功能，有习惯性便秘的人最适合用蔬菜果汁来调整体质。
现在的家居生活都讲求时尚简单，如果说低碳成为了节能减排的代名词的话，那么家电绝对是低碳的先行者，因为家居生活所用到的燃气和电能都是消耗比较大的，所以一些低能耗的产品受到欢迎。
本文所设计的自动化离心式水果榨汁机，主要包括齿轮机构的设计，轴的安装及校核，轴承的选型计算，载荷的确定，总体的布局以及电机进行选型，最后废料回收装置以及出汁口进行设计。
，根据设计参数，针对工作中存在的情况，进行了关键部件的选型设计以及校核，最后根据理论参数，对离心水果榨汁机进行三维建模。
关键词: 榨汁机、结构设计、三维建模、复杂性AbstractWith the development of modern, health issues have become the focus of attention, all kinds of health knowledge is becoming a topic of gossip, the fresh fruit juice is known by more and more people. Drink a cup of fresh fruit or vegetable juice every morning, increased activity and stable blood pressure and other functions, especially the old people and children, just eat fruit is not easy to digest, but not easy to absorb. Almost all vegetable juice has help defecation function, there habitual constipation person most suitable for vegetable juice to adjust physique. Now Home Furnishing life all about fashion simple, if low carbon has become synonymous with energy saving and emission reduction of words, then the appliance is absolutely is a forerunner of low carbon, because the use of Home Furnishing life gas and electric energy consumption is relatively large, so some low energy consumption products welcomed.In this paper, the design of automatic centrifugal fruit juicer, mainly including the design of the gear mechanism, installation and check of shaft, and bearing selection calculation, the determination of load, the overall layout and selection of motor, finally the waste recycling equipment and design of juice.Keywords：juicer the structure design 3d modeling and complexity第一章绪论1.1 论文概述目前榨汁机的消费群体主要有两类：一类是有孩子或老人的家庭，孩子容易挑食而老人牙齿不好，自己榨果汁可以满足他们摄入足够的营养；另一类是追求时尚及生活品位的年轻人，榨汁机满足了他们崇尚个性口味的需求。
榨汁机使用说明翻译
安全保护措施⏹ 请在使用前认真阅读所有说明。
⏹ 确保所使用的电压与产品标明的相匹配。
⏹当有插头螺丝等零件损坏，或无法正常使用，或机器被摔、被损坏、被浸水时，千万不要启动机器。
请将产品送到授权的专业维修中心检测维修。
不要自行拆开产品维修。
⏹为了避免触电，请勿把电机装置浸在水中或任何其它液体中。
手湿时不要触碰插头。
⏹当小孩接近产品时请注意监管。
请勿把产品放在小孩能接触到的地方。
确保小孩远离电线。
⏹确保产品在组装、拆卸、清洁和停止使用时没有连接电源。
⏹确保每次使用后关掉开关。
在卸下碎肉杯等部件前确保机器停止运作。
⏹ 请勿让运作中的产品无人看管。
⏹ 产品出现失灵或故障后，请关掉开关。
⏹ 确保在平面上使用本产品。
⏹ 请勿在热表面或明火旁使用本产品。
⏹ 刀口锋利，小心使用。
⏹ 请勿在果肉储藏格未组装上的情况下使用。
⏹ 避免接触正在运作的部件。
⏹保证产品运作时盖子卡紧，运作时不要松开盖子。
⏹产品运作时不要伸入手指。
不要用手直接放入食物，请使用推杆。
当不允许时，将机器关掉然后再拆开取出卡住的食物。
⏹不遵照制造商的建议使用产品可能会导致火灾，触电或受伤。
⏹ 请不要在户外使用。
⏹本产品只允许家庭使用。
本产品购买来即组装完成状态，建议第一次使用前先用温水清洗，以防制造及运送过程中的灰尘残留。
产品部件清单（对照说明书封面内页的图片）1. 电机装置 （序号对应图片）2. 开关3. 果肉储藏器4. 果汁杯5. 不锈钢刀片/滤网6. 榨汁机盖子7. 食物推杆产品使用拆卸1. 移开食物推杆（7）。
2. 把手分别放在榨汁机盖子（6）的两边然后轻轻地将盖子按顺时针方向转大约两英寸然后再轻轻松开。
3. 将一次性将剩下两部分拆卸。
（将手分别放在果汁杯（4）两侧，然后轻轻地按顺时针方向旋转整45。
这会使不锈钢滤网（5）自动与电机分离。
）4. 将果汁杯提起，不锈钢滤网将与其分开。
组装1. 将果汁杯（4）安装在电机装置（1）的中心，确保果汁杯里的小塑料扣环紧扣在电机装置的狭缝上。
榨汁机使用手册
机身材质：镀银高档涂层（优于不锈钢）
渣桶容量：2.0L
产品净重：4.5KG（普通榨汁机只有3.5KG左右，看重量就知道产品用料是否厚实）本款榨汁机清洗很方便，只是刀网清洗的时候大家要注意水从刀网的背面往里冲洗，这样果汁丝就很容易冲洗干净，我们还会配一个小毛刷，清洗更方便。
4.这款产品的外壳是PP料喷涂高档银色涂层，结实耐用，外观更上档次，我们店铺还有一款不锈钢外壳的，相比之下，这款产品外表更容易清洁，不锈钢的成本和这款PP喷涂外壳的成本差不多。并且不会产生污点。这款产品同时也通过了欧盟的ROHS环保认证（2006年8月开始进入欧盟的产品都必须通过ROHS认证，现在中国和东南亚地区的电器还没有强制要求）
产品品牌：Hauswirt
型号：HJE800S
官方网站：
出口国家：欧洲（德国、俄罗斯等）
产地：广东珠海
产品尺寸：35*22*43cm
产品电压：AC220V/50HZ
产品功率：800W(大功率、出汁高）
转速：一档13000转/分；二档21000转/分
2.电子版果蔬汁56种制作方法，带功效，请向店主索要。
本款机器功率是800W，市面上常见的榨汁机的功率一般是600-700W，很多厂家因技术和成本原因做不了800W的，作为榨汁机，功率是最主要的技术参数，功率越大，出汁率就越高，因为转速快，有些人机器明明是700W的，转速却标上20000转每分钟，实际稍微等点电机技术的人就知道是假了，欺骗消费者，700W最多也就是15000转每分钟，这是基本原理.大家可以从国际购物网站上搜索一下，欧洲市场上很多卖100欧元的榨汁机一般是800-1000W之间，没有700W低功率的，因为低功率出汁低，对水果浪费很大，榨一个月的水果，浪费的钱就够买一台好的榨汁机的了,请大家慎重购买，不要用了几次感觉新鲜，以后再用觉得出汁低，太浪费了，这样你的榨汁机就成了摆设了，所以，一定要购买大功率的榨汁机。此款就是您的最好选择！！
榨汁机的操作规程(3篇)
第1篇一、准备工作1. 提前阅读说明书，了解榨汁机的功能、特点、注意事项等。
2. 检查榨汁机外观是否有损坏，如有损坏，请及时联系售后服务。
3. 准备所需的水果、蔬菜，洗净并切成适合榨汁的大小。
4. 确保操作环境干燥、通风，避免水源和潮湿环境。
5. 提前准备好所需容器，用于盛放榨出的果汁。
二、操作步骤1. 将榨汁机放置在平稳的桌面上，确保机器稳定。
2. 将水果、蔬菜放入榨汁机的容器中，注意不要放得过满，以免影响榨汁效果。
3. 将容器放在电机底座上，确保对准卡槽，防止容器滑动。
4. 盖上容器上的盖子，确保盖子密封良好。
5. 插上电源插头，接通电源。
6. 根据榨汁机说明书，选择合适的旋转速度。
一般而言，含水分较多的水果蔬菜选择快键，如西瓜、西红柿、橘子、橙子等；含水分较小的水果蔬菜选择慢键，如芹菜、胡萝卜等。
7. 按下榨汁机上的启动按钮，开始榨汁。
若需要间歇旋转，可使用瞬时键。
8. 榨汁过程中，注意观察榨汁机的工作状态，如有异常，立即停机检查。
9. 榨汁完成后，关闭榨汁机，断开电源。
10. 将榨出的果汁倒入提前准备好的容器中，可根据个人口味添加适量的糖、蜂蜜等调味料。
三、清洁与保养1. 榨汁完成后，立即关闭榨汁机，拔掉电源插头。
2. 将榨汁机容器、盖子、刀片等部件取出，用清水冲洗干净。
3. 使用软布擦拭榨汁机外部，避免使用粗糙的布料或硬质刷子，以免划伤表面。
4. 定期检查榨汁机各个部件的磨损情况，如有损坏，及时更换。
5. 存放榨汁机时，避免阳光直射，放置在干燥、通风的环境中。
四、注意事项1. 操作过程中，切勿将手或异物伸入榨汁机内部，以免造成伤害。
2. 避免将硬质水果、蔬菜直接放入榨汁机中，以免损坏刀片。
3. 榨汁过程中，如遇堵塞，切勿强行取物，应先关闭榨汁机，拔掉电源插头，待机器冷却后再进行处理。
4. 严禁将榨汁机置于高温、潮湿环境中，以免影响使用寿命。
5. 定期清理榨汁机内部的残渣，避免堵塞。
6. 请勿将榨汁机放入洗碗机中清洗，以免损坏。
SANTOS 压力杆榨汁机 #10 和 #70 使用和维修说明书
使用和保养说明书重要：请妥善保管本说明书中所包含的文件：•EC合格声明书•保修证明原版请在开箱前阅读使用说明书。
Coffee grinders - Fruit juicers - Mixers - Blenders - Drinks dispensers - Planetary mixersCheese graters - Ice crushers - Mincers - Vegetable slicers – Dough mixer咖啡磨豆机 – 水果榨汁机 – 拌和机 – 搅拌机 – 自动装饮料机 – 行星式拌和机 – 奶酪刨 – 碎冰机 – 绞肉机 – 切菜机– 和面机在法国和国际注册的型号INTERNATIONALLY PATENTED MODELS!#10 #70目录EC合格声明书 ......................................................................................... E rreur ! Signet non défini.安全规则 (4)禁忌： (4)电气连接： (4)第一次开始使用（图A ） (5)产品回收利用 (5)设备说明 (6)使用设备 (6)开始使用： (6)制备和使用： (6)清洗： (6)维修 (7)备件： (7)故障排除帮助 (8)设备无法启动： (8)设备因马达发热而停机： (8)设备因过热而停机： (8)马达运行但子弹头不转动： (8)参考标准 (9)设备的技术特性 (9)电气图 (10)图 (11)保修证明 (13)设备铭牌 (13)制造商：SANTOS SAS - Roger SALENGRO街140-150号 69120 VAULX-EN-VELIN （里昂）法国声明设备供专业市场使用，名称如下：名称：压力杆榨汁机型号：10, 10C, 70, 70C符合：•欧盟“机械”指令2006/42/EC附件1的法规条款及由其转化的本国法律规定。
- 1、下载文档前请自行甄别文档内容的完整性，平台不提供额外的编辑、内容补充、找答案等附加服务。
- 2、"仅部分预览"的文档,不可在线预览部分如存在完整性等问题,可反馈申请退款(可完整预览的文档不适用该条件!)。
- 3、如文档侵犯您的权益，请联系客服反馈,我们会尽快为您处理(人工客服工作时间：9:00-18:30)。
苏泊尔SJ207A-700榨汁机使用说明书
性能特点:
1.可榨多种水果、蔬菜及随意混合的水果蔬菜.
2.组合式结果，拆装简单，清洗方便。
3.安全保护装置，正确安装后，方可开机
4.在音效，岀汁多，电源线好收藏。
安全注意事项：
1.使用时人请勿离开机器，切勿让儿童接近或者使用本机
2.本机使用交流220W/50Hz的电源，使用前请确认
3.请使用本机配备的榨汁棒，不可使用其他产品代替
4.每次使用，一定要确保配件安装正确，且充分扣紧
5.机器运行时严禁打开盖子，在未拔掉电源时，切勿把手或
其他物品放入榨汁机内
6.机器运行时不要将果汁桶拿走，当关掉电源待机器已经停
止运转后才可拆洗，拆卸部件。
7.主机必须放在平稳的桌面上使用
8.主机部分严禁直接浸入水中或者用水冲洗，以免进水造成
机器故障，擦拭主机时必须先断开电源
9.所有配件严禁放入高温消毒柜内
10.本机使用初期因电机运转磨合阶段，所以有轻微异味，属
正常现象，待电机使用一段时间后上述现象会自动消失11.请勿使用较硬食品和含纤维成分较高的食物，对机器损伤
会很大
12.本机的刀片锋利，清洗时注意安全
13.使用时如果本机但愿线损坏，为避免危险，必须由我公司
的维修部或公司指定的特约维修点专职技术人员来更换。