海尔机器人冰箱NM952 零件清单及维修指南说明书

This parts list contains the service parts and
wiring diagrams for this model. Check the model
number in question to be sure that it is applicable
to this parts list.
TABLE OF CONTENTS
Cabinet (2)
Air Cooled Refrigeration (3)
Water Cooled Refrigeration (4)
Water System (5)
Gearmotor (6)
Evaporator (7)
Control Box (8)
Wiring Diagrams (9)
1
2
3
4
6
5
8
10
11
13
3
14
AIR COOLED
16
ITEM
PART NUMBER NUMBER DESCRIPTION 902-2976-01Filter Assembly 10A31462-001Tube Bracket 11A31461-001Tube Bracket
12A34039-001Control Box Support 13
A32435-001Left Side Panel, Painted A32435-002Left Side Panel, S.S. 1403-1404-12Screw
15A33252-001
Rear Panel, Water Cooled Painted Only 16.
A34042-001
Base
Water Cooled
15
ITEM
PART NUMBER NUMBER DESCRIPTION 1A33233-001Condenser Support 2
A33256-001Top Panel, Painted A33256-002Top Panel, S.S.
3A34038-001Service Panel, Painted A34038-002Service Panel, S.S.
4A33292-001Right Side Panel, Painted A33292-002Right Side Panel, S.S.503-0271-00Speed Clip 615-0711-01Emblem 703-1419-08Screw
8
A33255-001Front Panel, Painted A33255-002
Front Panel, S.S.
Cabinet Assembly
NM952 SERVICE PARTS
11
19
18
17
1514
1312
1
3
4
5
6
7
10
8
9
20
16
2
NOTE: 60 cyele replacement compressors include a crankcase heater which was not part of the original design.The crankcase heater may be
used or disconnected.
ITEM PART NUMBER NUMBER DESCRIPTION 1218-6800-01Grommet 1318-2300-27Sleeve 1403-1407-07Washer 1503-1405-20Cap Screw 1602-2426-02Dryer
17A33231-001Fan Shroud 1818-8717-01Condenser
19A33233-001Condenser Mount 20
18-8716-23Compressor 208-230/60/118-8716-25Compressor 200-230/60/318-8716-26Compressor 220-240/50/1(18-8716-26 for 50 cycle only)
all compressors have internal overloads
18-8716-23, 18-8716-25 have crankcase heaters
ITEM PART NUMBER NUMBER DESCRIPTION 118-3815-01Fan Blade 212-1576-02Fan Motor 302-2378-01Fan Bracket 403-1531-01Screw
5A32961-020Insulation Kit (3 piece)611-0477-20Thermo Expansion Valve 7A35566-001Suction Line 8A32890-020 Evaporator 916-0832-20Access valve 9a 16-0832-02Stem cap 9b 16-0832-03Core cap 1011-0446-27Hi Pressure Cut Out 1103-1645-01 Screw
9a 9b
1
2
3
4
5
7
8
9
10
6
12
13
14
15
17
11
NOTE: Replacement
Compressors include a
crankcase heater which was
not part of the original design.
The crankcase heater may be
used or disconnected.
19
1216-0832-20Access Valve
12a16-0832-02Stem cap
12b16-0832-03Core cap
1311-0446-27Hi Pressure Cut Out
1416-0401-02Elbow
1511-0424-21Water Reg. Valve
1603-1403-14Screw
17A34044-001Drain Assembly
1818-8716-23Compressor 208-230/60/1
18-8716-25Compressor 200-230/60/3
18-8716-26Compressor 220-240/50/1
(all have internal overloads & 18-8716-23,
18-8716-25 have crankcase heaters)
1902-3319-02Dryer
ITEM PART
NUMBER NUMBER DESCRIPTION
118-8718-25Condenser
203-1645-01Screw
311-0477-20Thermo Expansion Valve
4A32961-020Insulation Kit (3 piece)
5A35566-001Suction Line
6A32890-020Evaporator
703-1405-20Cap Screw
803-1407-07Washer
918-2300-26Sleeve
1018-6800-01Grommmet
1103-1645-01Screw
12a
12b
122
21
18
20
16
17
15
14
13
10
89
8
712
6
27
23
19
20
23
25
24
26
ITEM
PART NUMBER NUMBER DESCRIPTION 14A32050-001Drip Pan
15A27318-001Water Inlet Fitting 1603-1394-01Pal Nut
1713-0079-03Res. Overflow, 8" req.18A34045-001Drain Casting, air cooled 1913-0704-00Gasket 2002-2814-08Clamps
2113-0674-06Evap. Drain, 14" req.2213-0840-01Plug
2313-0674-06Evap. Inlet Tube, 5" req.2416-0670-01Tee
25A33203-001Tube, Preformed 2613-0079-03Drain Tube, 24" req.27.03-1417-13
Lockwasher
ITEM PART NUMBER NUMBER DESCRIPTION 103-1420-03Cap Screw
2A33101-022Water Level Sensor 3A32890-020Evaporator 402-2936-01Res. Cover
5A32922-020Float Assembly with pin housing seal, rubber seat, insert & float 02-3190-01Rubber seat
6A32929-020Reservoir Assy Complete 7A32777-001Retaining Ring for seal 816-0791-01Half Union 916-0162-00Strainer 1013-0079-03Tube, 3.2" req.1116-0670-02Tee 1202-0929-23Water Seal 1313-0868-01Water Shed
10
11
12
13
8
9
7
6
5
3
2
1
*NOTE: GEARCASE COVER INCLUDES COVER, OUTPUT SHAFT, KEY, OUTPUT GEAR, BEARINGS
AND SEAL
ITEM PART NUMBER NUMBER DESCRIPTION 113-0868-01Water Shed 2A32379-029Seal 3no number End bell 4A32379-026Bolt
5A32379-022Gearcase Cover*
6A32379-0241st Gear and Bearings 7A32379-0232nd Gear and Bearings 8A32379-021Gasket 9A32379-020Gearcase
10
12-2430-24Start swtich, Emerson 12-2430-44Start sw, GE split phase
1112-2430-22Drive Motor 208-2301212-2430-29Rotor Bearing, Emerson
12-2430-49Rotor bearing, GE split phase
13A32379-028Seal 14A32379-027Oil, 1 Container 15A33220-022
Complete Assembly
208-230 volt
Complete assembly includes water shed and drip pan gasket.
A33220-030Gears, oil & covers. No motor
Not Illustrated:
Bail Clamp, pn
A34969-001
4
3231 30
29
28
27
26
29
23
25
21
24
19
18
17
16
15
13
12
11
10
8
8
6
5
4
3
2
1
ITEM PART
NUMBER NUMBER DESCRIPTION
1.02-2933-01Hex Stud
2.A32891-020Switch assembly
13-0617-53O-ring
12-2398-01Manual reset switch
3.02-2930-01Ice Chute Cover
4.A32963-001Insulation Top (half)
5.02-2926-01Ice Chute Body
6.A33102-001Insulation Collar Inside
A35419-020Strap kit
7.02-2929-01Ice Chute Lower
8.A37708-021Bin Controls Assy.
(set of 2)
9.A32930-001Chute Gasket
10.03-1405-52Hex Cap Screw
11.02-3001-01Ice Sweep
12.13-0871-01Water Shed
13.02-2978-01Lip Seal
14.02-2138-20Breaker Cover
15.13-0617-54O-Ring
16.08-0660-01Auger Stud, includes 17
17.no number Thrust Washer. part of
item 16
18.A34559-020Bearing
19.02-2977-01Lip Seal
20.no number
21.13-0617-52O-Ring
22.no number
23.13-0617-45O-Ring
24.03-1544-08Soc. Head Screw
25.A32900-020Breaker
(includes 13,14,15, 18,19 & 23)
26.A38071-022Auger
27.A32890-020Evaporator
28.03-1405-41Cap Screw
29.A32962-001Insulation Bot. (half)
30.A32050-001Drip Pan
31.13-0704-00Drip Pan Gasket
32.13-0868-01Water Shed
Evaporator
NM952 SERVICE PARTS
9
10
117
6
3
5
1
8
2
4
12
ITEM PART NUMBER NUMBER DESCRIPTION
118-1901-15Start Capacitor,60Hz 18-1901-23Start Capacitor,50Hz 18-2200-38Start Capacitor Cap.2.18-2200-39Start Capacitor Bracket 03-1638-04Screw
03-1417-15Lockwasher
3.A32872-001Run Cap Bracket 03-1652-02Bolt
03-0255-04Wing Nut 4.03-1638-03Screw
5.18-1902-53Run capacitor,all
6.
12-2469-02Single Phase Contactor 12-0739-02
Three phase contactor
Note:Hz means Cycles,50Hz is 50cycle,the
model number ends in a -6for 50Hz models.
ITEM PART NUMBER NUMBER DESCRIPTION 7A37750-021Circuit Board 8.12-0426-01Master Switch 9.11-0447-20Low Pressure Control 10
18-1903-33Potential Relay,all Hz 18-1903-46Potential relay,50Hz
11.12-2285-22Transformer 12no number Control Box NOT ILLUSTRATED 13.12-2337-023Pin Plug Assy
(Safety Circuit to Circuit Board)
14.12-2340-014Pin Plug Assy
(Transformer to Circuit Board)
15.A34055-001Control Box Cover
Control Box
NM952SERVICE PARTS
NM952 SERVICE PARTS AIR AND WATER COOLED, 208-230/60/1
AIR AND WATER COOLED, 208-230/60/1
USE COPPER CONDUCTORS ONLY
ALL CONTROLS SHOWN IN NORMAL ICEMAKING MODE THIS UNIT MUST BE GROUNDED
AIR AND WATER COOLED, 208-230/60/3
AIR AND WATER COOLED, 208-230/60/3
USE COPPER CONDUCTORS ONLY
ALL CONTROLS SHOWN IN NORMAL ICEMAKING MODE THIS UNIT MUST BE GROUNDED。