Fire Protection Impairment Program消防系统中断管理程序

Fire Protection Impairment Program

消防系统中断管理程序

1.Purpose目的

To follow the procedure when a fire protection system is out of service so as to ensure the risks are minimized and the duration of the impairment is limited as well as the damage of the personnel and facility.

通过严格控制消防系统中断过程中各环节来减少以至于最终杜绝消防系统的失效时间，保证消防中断期间潜在的风险对受影响区域的人员和设施的损坏降低到最小。

2.Scope范围

This policy applies to all factory employees, contractors and their representatives to provide service when the fire system is impaired partially or totally.

本程序适用于在工厂里工作的雇员，承包商或者他们的代表在工作过程中将要对当前使用的消防系统造成部分或全部功能中断时。

3.Definition定义

Fire Protection System: Sprinkler systems, standpipe systems, fire hose system, underground fire service mains, fire pumps, water storage tanks, foam-water system, special extinguishing system, fire service control valves, fire alarms, and emergency lights.

消防系统：

指喷淋系统，消防软管，地下消防水管，消防泵，消防水罐，泡沫灭火系统，消防控制阀，火灾报警系统以及应急灯等与消防有关的设备设施。

Fire watch: A person designated to physically patrol the area where the fire protection system is impaired.

看火员：当一个区域的消防系统处于中断状态之后，被指派到该区域专门巡视该区域的专业人员。

Fire system impairment: A shut down, in whole or part of a fire protection system. According to the situation, the impairment can be divided into the following:

消防系统中断：消防系统中断系指消防系统部分或者全部丧失其设计的消防功能的状态，根据现场实际，消防系统中断主要分以下几种：

●Emergency impairment: when a fire protection system is out of service due to an

unexpected incident such as a ruptured pipe or unexpected power-off.

●应急中断：消防系统由于不可预知的事件发生时而导致的系统消防功能丧失，此种

情况比如管线意外破裂或者意外的系统断电时。

●Planned impairment: When a fire system is out of service in whole or part due to a plan

in advance such as revisions to the water supply or sprinkler piping system.

●计划中断：消防系统由于提前计划规定在某段时间内功能部分或者全部丧失，比如

消防管网或者雨林系统的升级改造等。

●Level 1 impairment: when a limited number of a component of a fire protection system

are found detective or removed from performance. Level 1 impairment means a minimal impact to the overall life safety of the occupants.

●1级中断：当少量的重要设备及其组成部分有故障或者从系统拆除之后该消防系统

所处的状态，一般对系统的整体功能的影响最小。

●Level 2 impairment: A shutdown of the entire fire protection system or major portion,

significantly affecting occupant life safety.

●2级中断：整个消防系统完全关停，或者中断对消防系统的主题功能造成了实质性

影响。

Impairment Coordinato r: The person designated by SE manages the impairment while system service is being performed. The director of the Healthy and Safety or the manager of the Department of the Environment will be the Impairment Coordinator.

中断协调员：

为了保证在消防系统中断整个过程中严格执行中断程序，SE特别设置此协调员，一般为工厂的健康，安全，环境的经理担当此任务。

4.Responsibility 责任

SE employees：

All the employees who impair a fire protection system, in whole or part, must first notify the Impairment Coordinator at the Department of the Environmental Health and Safety. If the impairment permit is required, the employees will attach the Fire & Life Safety System Permit or Impairment Tag (schedule A) to fire department connection for the sprinklers system impairment or the control panel for the fire alarm systems, and then issue the Permit to Work License of Fire Control Facility based on the “Management Procedure of Safety Work Permit”.

SE 雇员：

任何一个雇员在工作过程中有可能全部或者部分中断一个系统的消防功能时，必须第一时间报告环保健康安全部门的中断协调员，经研究如果确实需要消防系统中断，则从中断协调员那里申请一个防火逃生许可/中断标牌（见计划A），并将此防火逃生许可/中断标牌挂在消防中断区域的喷淋系统阀组或者是火灾报警盘上, 然后再按照《安全工作许可证管理程序》开具在消防设施上开展施工的作业许可证。

Contractor or Outside Company Representatives:

Any contractor or the Outside Company Representatives who impair a fire protection system, in whole or part, must first notify the Impairment Coordinator at the Department of the Environmental Health and Safety. If the impairment permit is required, any contractor or the Outside Company Representatives will attach the Fire & Life Safety System Permit or Impairment Tag (schedule A), which would be a precondition to apply for work permit before starting the operation, to fire department connection for the sprinklers system impairment or the control panel for the fire alarm systems.

合同商或者外部公司代表：任何合同商或者外公司代表在工作过程中有可能全部或者部