weldingmetallurgy焊接冶金
Welding_Metallurgy焊接冶金知识要点
Shielded Metal-Arc Welding（手工电弧焊）Shielded Metal-Arc Welding手弧焊使用外壳覆盖着熔渣混合物的钢条或者金属丝为电极，如图1。
T hese coating s这些药皮是通过精确计算加工成型的，在焊接过程中有重要的作用。
如稳定电弧，保护熔滴，控制熔滴的粘稠度，保护焊道的固化以及冷却至室温等。
焊丝药皮的化学组成和在手弧焊的作用将在第三章详细讨论。
When automatic machine当自动焊机用于手弧焊时，我们就会遇到焊接电流向电极传递的问题，显然如果焊丝中覆盖着熔渣混合物构成的固体药皮的话，会严重影响电流的传递。
If the electrode如果焊丝是直的并且不长的话，我们会像手工焊一样，让其通过端部接触。
而对于长焊丝，当电流流过时由于自身的大电阻作用会发热。
Generally w e一般来说我们希望将焊丝绕成圈进行自动焊接，因而需要用一个设备将电流合理的引到焊丝的电弧端。
使用涂有较厚药皮的成卷焊丝是有可能的，我们可以使用一个自动头来对其进行供给，该自动头的药皮上切了一个狭窄的缝使导电块能接触焊丝。
进一步改进就是一种成卷的涂有药皮的电极，这种电极有一个较小直径的焊丝仅仅缠绕在较大直径焊条的表面，而且暴露在药皮的表面，小直径的焊丝从自动焊接头的导电块向大直径的焊条通电流，很多赶紧的方法被用来克服通电流的问题。
Flash Welding（闪光焊）While this pocess is虽然闪光焊和顶锻焊非常相似，但由于操作过程不同使它们有不同的特点.a flash weld 在闪光焊中，被焊工件用铜片夹紧轻触对接.a current电流通过结合点.heat is 热量大体上产生于接触电阻的轻微短路，这个过程在接触面上连续且相当快速的发生.在接触面上表面金属快速熔化并且金属中白热部分从接头飞溅出去.this flashing action这个闪光过程有时被错误的认为是电弧，工件被慢慢地推进，用来补偿闪光过程中的金属损失，从而使它持续发生.when the entire 当整个临近表面被熔化，停止通电流，紧接着两工件在合适的压力下连接在一起.a thin film一层薄膜或金属毛刺被从接头中挤出，通过这种方法，在接头中任何被氧化的金属都很容易被消除，并且接头截面的变形量明显要小。
冶金专业英语词汇(M)
冶金专业英语词汇(M) 冶金专业英语词汇(M) machinability 可切显machinability annealing 改善加工性的退火machinable cast iron 可淆铁machine casting 机械化铸造machine charging 机械装料machine molding 机旗型machine side 推焦侧machine welding 机械化焊接machine work 机械加工machinery casting 机械化铸造machining 机械加工machining allowance 加工余量machining property 可切显mackintoshite 黑铀缸矿macle 双晶macro analysis 常量分析macro etching 宏观浸蚀macroaxis 长轴macrocrack 宏观裂纹macrogranular structure 粗粒组织macrograph 宏观组织相片macrographic test 宏观照相检验macrography 宏观检验macroscopic segregation 宏观偏析macroscopic stress 宏观应力macroscopic structure 宏观组织macrosection 宏观磨片macrosegregation 宏观偏析macrostress 宏观应力macrostructure 宏观组织mag coke 镁焦magnalium 马格纳利乌姆铝镁铸造合金magnesia 苦土magnesia brick 镁砖magnesia carbon brick 镁碳砖magnesia carbon refractory 镁碳质耐火材料magnesia cement 菱镁土水泥magnesian lime 镁石灰magnesian limestone 镁质石灰岩magnesioferrite 镁铁矿magnesite 菱镁矿magnesite brick 镁砖magnesite dolomite refractory 镁质白云石耐火材料magnesite lining 镁砂内衬magnesite refractory 镁质耐火材料magnesium 镁magnesium alloy 镁合金magnesium base alloy 镁基合金magnesium chloride 氯化镁magnesium nitride 氮化镁magnesium oxide 氧化镁magnesium sulfate 硫酸镁mag 磁石mag crane 电磁铁起重机mag steel 磁石钢magic aftereffect 磁性后效magic aging 磁时效magic alloy 磁性合金magic analysis 磁分析magic anisotropy 磁蛤异性magic annealing 磁性退火magic blowout 磁吹熄弧magic circuit 磁路magic concentration 磁力选矿magic crack detection 磁力探伤法magic cycle 磁化循环magic domain 磁畴magic field 磁场magic field intensity 磁场强度magic field strength 磁场强度magic filter 磁性过滤器magic flaw detection 磁力探伤法magic flaw detector 磁力探伤器magic flux 磁通magic flux density 磁通密度magic hammer 磁性锤magic hysteresis 磁滞magic induction 磁感应magic inspection 磁力探伤法magic iron ore 磁铁矿magic material 磁性材料magic moment 磁矩magic needle 磁针magic permeability 磁导率magic polarization 磁极化magic pole 磁极magic potential 磁位magic properties 磁特性magic pyrite 磁黄铁矿magic quantum number 磁量子数magic resistance 磁阻magic rigidity 磁刚性magic saturation 磁性饱和magic separation 磁选magic separator 磁力选矿机magic susceptibility 磁化率magic transformation 磁性变化magic viscosity 磁粘性magically hard alloy 硬磁合金magically soft alloy 软磁合金magism 磁性magite 磁铁矿magite concentrate 磁铁精矿magization 磁化magization curve 磁化曲线magizing 磁化magizing force 磁化力magizing roasting 磁化焙烧magograph 磁强记录仪magography 磁记录法magometer 磁强计magometric analysis 测磁分析magomotive force 起磁力magostriction 磁致伸缩magostriction constant 磁致伸缩常数magnification 放大倍数main deformation 治变main drive 肢动main frequency furnace 工频电炉main roof 织顶main table 工柞道maitlandite 钍铅铀矿malachite 孔雀石malacon 变水锆石maldonite 黑铋金矿malleability 可锻性;可塑性malleable iron 可锻铸铁malleablizing 韧化mallet 木锤malmstone 砂岩mandrel 芯杆mandrel bar 芯棒mandrel coiler 筒式卷取机mandrel die 舌形组合模mandrel drawing 长芯棒拔制mandrel extractor 芯棒抽出机mandrel holder 芯棒座mandrel mill 芯棒式无缝管轧机mandrel stripper 芯棒抽出机mandrel stripping 芯棒抽出mandrel uncoiler 卷筒式开卷机manganate 锰酸盐manganese 锰manganese brass 锰黄铜manganese bronze 锰青铜manganese chloride 氯化锰manganese dioxide 二氧化锰manganese dithionate 过二硫酸锰manganese green 绿锰矿manganese iron 含锰生铁manganese killed steel 锰镇静钢manganese ore 锰矿manganese oxide 氧化锰manganese steel 锰钢manganese sulfate 硫酸锰manganese superoxide 过氧化锰manganese yield 锰收得率manganic acid 锰酸manganic oxide 三氧化二锰manganic salt 正锰盐manganin 锰铜manganite 亚锰酸盐manganosite 方锰矿manganous acid 亚锰酸manganous oxide 氧化亚锰manganous salt 亚锰盐mangling 矫直manipulation 操纵manipulator 操纵器;推床manipulator slide beam 推床的导板mannesmann mill 带桶形轧辊的穿孔机mannesmann piercer 带桶形轧辊的穿孔机mannesmann process 曼内斯曼轧管法manometer pressure 计示压力mantle 铁罩mantle ring 炉身托圈manual welding 手工焊接manufacturing process 生产过程maraging 马氏体时效maraging steel 马氏体时效钢marble fracture 大理石状断口marcasite 白铁矿margin 边缘marine corrosion 海水腐蚀mark 痕迹market brass 普通黄铜marking 标志marl 泥灰土marl brick 泥灰岩砖marmatite 铁闪锌岩marsh gas 沼气martempering 马氏体等温淬火martensite 马氏体martensite finish point mf 点martensite plate 马氏体片martensite point 马氏体转变点martensite start point ms 点martensite structure 马氏体组织martensitic aging 马氏体时效martensitic phase 马氏体相martensitic range 马氏体区域martensitic steel 马氏体钢martensitic transformation 马氏体转变martin furnace 平炉martin process 平炉炼钢法martite 假像赤铁矿martite concentrate 假像赤铁矿精矿mash 矿浆mash seam welding 滚压电阻缝焊mass 质量mass action 质量酌mass analysis 质量分析mass concentration 质量浓度mass defect 质量筐mass effect 质量效应mass percent 质量白分比mass spectrograph 质谱仪mass spectrography 质谱分析法mass spectrometer 质谱分光计mass spectrometry 质谱分析mass spectroscopy 质谱学mass spectrum 质谱mass transfer 质量转移massicot 铅黄massive martensite 块状马氏体massive minerals 块状矿物master 标准规master alloy 中间合金master form 阴模master gage 标准规master pattern 原模型mat etching 变暗浸蚀mat surface 消光外表match plate 对型板material balance 物料平衡mathematical model 数学模型matrix 基体;模型;脉石matrix metal 基体金属matte 锍冰铜matte smelting 冰铜熔炼maximum load 最高负荷maximum permeability 最大磁导率maximum stress 最大应力mean error 平均误差mean free path 平均自由行程mean pressure 平均压力mean square error 均方误差mean stress 平均应力measuring apparatus 测量装置measuring cell 测力仪measuring head 移动定尺挡板measuring hopper 计量料包measuring instrument 测量仪器mechanical alloying 机械合金化mechanical anisotropy 机械性能蛤异性mechanical charging 机械装料mechanical classifier 机械分级机mechanical cleaning 机械清理mechanical descaling 机械除鳞mechanical energy 机械能mechanical equivalent of heat 机械的热当量mechanical metallization 机械金属化mechanical metallurgy 加工冶金学mechanical mixture 机械混合物mechanical molding 机旗型mechanical passivity 机械钝态mechanical plating 机械镀覆mechanical polishing 机械抛光mechanical press 机械压力机mechanical properties 机械性质mechanical rammer 缓冲器mechanical strength 机械强度mechanical stress 机械应力mechanical stripping 机械脱模mechanical test 机械性能试验mechanical tube 结构用管mechanical twin 形变孪晶mechanism 机构medium 介质medium carbon steel 中碳钢medium plate 中板medium section mill 中型轧机medium shape 中型型钢meehanite 米哈奈特铸铁melaconite 黑铜矿melanite 黑榴石melt 熔解melt backing 焊药垫melt down period 熔化期melt through 焊穿meltability 可熔性meltdown 熔化melter 熔炼炉melting 熔解melting furnace 熔炼炉melting heat 熔化热melting loss 熔化损melting point 熔点melting pot 熔化锅melting temperature 熔化温度melting zone 熔化带membrane 膜mendelevium 钔meniscus 弯月面merchant bar 商品条钢merchant iron 商品条钢merchant mill 小型轧机mercuric pound 正汞化合物mercurous pound 亚汞化合物mercury 汞merit number 质量指标mesh 筛目mesh analysis 筛分析mesh number 筛号mesh size 筛孔径metacinnabarite 黑辰砂矿metal 金属metal arc inert gas welding 金属惰性气体电弧焊metal arc welding 金属弧焊接metal bath 金属浴metal beating 金属的锤还薄metal carbonyl 羰基金属metal cased brick 铁皮砖metal cementation 渗金属法metal ceramic technique 金属陶瓷法metal ceramics 金属陶瓷metal charge 金属装料metal coating 金属敷层metal deposit 熔敷金属metal electrode 金属电极metal fall 金属提取率metal fog 金属雾metal foil 金属箔metal forming 金属成形metal gauze 金属网metal intensity 金属单位消耗量metal level control 金属液面第metal loss 金属烧损metal mold 金属铸型metal pattern 金属模metal peration 机械粘砂metal physics 金属物理学metal pickup 金属粘接metal powder rolling mill 金属粉末轧机metal products 金属制品metal scrap 废金属metal sheet 金属板metal spraying 金属喷镀metal sticking 金属粘接metal stream shrouding 金属粒护metallic bond 金属键metallic charge 金属装料metallic coating 镀金属metallic pound 金属化合物metallic crystal 金属晶体metallic element 金属元素metallic fume 金属烟气metallic glass 金属玻璃metallic inclusions 金属夹杂物metallic iron 金属铁metallic luster 金属光泽metallic paint 金属涂料metallic phase 金属相metallic ring 金属声metallic silicon 金属硅metallic solution 金属溶液metallic state 金属态metallicity 金属性能metallization 敷金属metallized charge 金属化炉料metallized sinter 金属化烧结矿metallizing 敷金属metallographer 金相学家metallographic etchant 金相腐蚀液metallographic examination 金相研宄metallographic microscope 金相显微镜metallographic microscopy 金相显微学metallographic section 金相试样metallographic specimen 金相试样metallographic study 金相研宄metallographic test 金相检验metallographist 金相学家metallography 金相学metalloid 类金属metalloscope 金属显微镜metalloscopy 金属显微检查metallostatics 金属静力学metallothermics 金属热复原法metallothermy 金属热复原metallurgical chemistry 冶金化学metallurgical coke 冶金焦metallurgical furnace 冶金炉metallurgical industry 冶金工业metallurgical length 冶金长度metallurgical process 冶金过程metallurgical reactor 冶金反响堆metallurgical works 冶金工厂metallurgist 冶金学家metallurgy 冶金metasilicate 偏硅酸盐metastability 亚稳定性metastable condition 亚稳态metastable equilibrium 准稳平衡metastable phase 准稳定相metastable state 亚稳态metatectic transformation 包晶转变metatungstate 偏钨酸盐meteoric iron 陨铁methane 甲烷method of impregnation 浸渍法method of least squares 最小二乘法meyer hardness 迈耶耳硬度mf point mf 点miargyrite 辉锑银矿miarolitic structure 晶洞状构造mica 云母micelle 胶粒microalloyed steel 微合金化钢microalloying 微量合金化microanalysis 微量分析microbiological leaching 微生物浸出microchemical analysis 微量化学分析microcline 钾微斜长石microconstituent 显微组织成份microcrack 微裂纹microcreep 微观蠕变microcrystal 微晶microelement 微量元素microetching 显微腐蚀microfissure 微裂纹micrograph 显微照片micrography 显微检验microhardness 显微硬度microhardness tester 显微硬度计microhardness testing 显微硬度试验microlite 微晶;细晶石microlitic structure 微晶体组织micromanometer 微压计micrometer 千分尺micrometer stop 千分尺定位器microphotographic apparatus 显微照相机microphotography 显微照相术microporosity 微观孔隙率microradiograph 显微射线像microsclerometry 显微硬度测定microscope 显微镜microscopic analysis 显微分析microscopic examination 显微镜检验microscopic segregation 显微偏析microscopic stress 微观应力microscopic structure 显微组织microsection 显微磨片microsegregation 显微偏析microshrinkage 显微缩孔microslice 显微磨片microstrain 微应变microstress 微观应力microstructure 显微组织microstructure analysis 显微组织分析microthrowing power 微观电镀本领middle flask 中间砂箱middle plate mill 中板轧机middle roll 中辊middlings 中间产品midland ross process 米德兰德罗斯法midrex process 米德雷斯直接炼铁法mig welding 金属惰性气体电弧焊mild steel 软钢mild steel plate 软钢板mild steel sheet 低碳钢薄板milk of lime 石灰乳mill 工厂mill approach table 轧机前的辊道mill bay 轧机跨mill edge 轧制的边mill finish 精轧mill hardening 轧制余热淬火mill housing 轧机机架mill layout 轧机布置mill opening 轧辊开度mill pack 叠轧板材mill pinion 齿轮辊mill scale 轧钢皮mill scale powder 轧钢皮粉mill screw 第螺钉mill setting 轧机蝶mill setup 轧机蝶mill speed 轧制速度mill springing 轧机机座的弹跳mill stand change 换机座mill table 轧机辊道mill torque 轧制力矩mill train 轧机机组milled powder 碎粉miller indices 密勒指数millerite 针硫镍矿milling 粉碎milling fluid 研磨液体milling liquid 研磨液体milliscope 金属液温度报警器mimetite 砷铅矿mine 矿山mineral 矿物mineral acid 无机酸mineral position 矿物组成mineral deposit 矿床mineral dressing 选矿mineral processing 选矿mineral salt 矿物盐mineral substance 矿物质mineral water 矿泉水mineral wool 渣棉mineralization 成矿酌mineralizing 成矿酌mineralogical analysis 矿物分析mineralogy 矿物学mite 鲕状褐铁矿mini mill 小型钢铁厂mini steel mill 小型钢铁厂mining 采矿minium 红铅minus sieve powder 筛下粉末minute adjustment 精调mirabilite 芒硝misch metal 混合稀土金属miscibility 溶混性miscibility gap 溶混间隔mismatch 不一致mismatch in mold 错箱misorientation 错取向misrun 浇不满miss rolling 欠轧mistrimmed forging 不正确切边的锻件mixed coke oven and blast furnace gas 焦炉与高炉混合煤气mixed crystal 固溶体;混合晶mixed dislocation 混合型位错mixed gas 混合煤气mixed joint 混合接头mixed potential 混合电位mixed scrap 混合废钢铁mixer 混合机mixer ladle 混铁炉式铁水罐mixer metal 混铁炉生铁mixing 混合mixing ladle 混铁炉式铁水罐mixing power 搅拌力mixing proportion 混合比mixing ratio 混合比mixing valve 混合阀mixture 混合物mixture heat 混合热mobile dislocation 可动位错mobile mixer 移动式混铁炉mobile phase 怜相mobility 迁移率model 模型model test 模型试验modification 变体modifier 变质剂modifying addition 改良剂modulated structure 形变织构module 模数modulus 模数modulus of elasticity 弹性模数modulus of pressing 压缩模量modulus of rigidity 刚性模数modulus of volume elasticity 体积弹性系数moebius process 莫比斯银电解法mohs hardness scale 莫斯硬度标moire fringe method 莫阿干预法moissanite 碳硅石moistening 湿润moistness 湿度moisture 湿分moisture content 含水量moisture meter 湿度计mol 克分子molar concentration 克分子浓度molar conductivity 克分子导电率molar heat capacity 克分子热容量molar ratio 克分子比molar solution 克分子溶液molarity 重量克分子浓度mold 型mold casting 型铸造mold cavity 铸模型腔;结晶苹mold clamp 模夹钳mold cooling jacket 结晶其却水套mold core 模芯mold dilatation 铸模膨胀mold dismantling 打箱mold jacket 模箱mold level 结晶期钢液面mold oscillation frequency 结晶岂动频率mold paint 铸型涂料mold saddle 铸模托台mold slag 铸模内渣mold stool 锭盘mold table 结晶岂动台mold taper 结晶票度mold wash 铸型涂料molded section 冷弯型钢molder 造型工;造型装置molder tool 造型工具molder's rule 收缩尺molding 造型;铸造;铸件molding box 型箱molding flask 型箱molding machine 造型机molding material 造型材料molding sand 型砂mole fraction 克分子分数molecular crystal 分子结晶molecular distillation 分子蒸馏molecular lattice 分子晶格molecular mass 分子质量molecular sieve 分子筛molecular weight 分子量molecule 分子molten bath 熔融浴molten metal 熔融金属molten pool 熔池molten salt 熔融盐molybdate 钼酸盐molybdenite 辉钼矿molybdenum 钼molybdenum base alloy 钼基合金molybdenum chloride 氯化钼molybdenum disulfide 二硫化钼molybdenum glance 辉钼矿molybdenum ore 钼矿molybdenum oxide 氧化钼molybdenum steel 钼钢molybdenum sulfide 硫化钼molybdic acid 钼酸molybdic acid anhydride 钼酸酐molybdite 钼华monazite 独居石monazite sand 独居石砂mond process 蒙德法monel 蒙奈尔铜镍合金monel metal 蒙奈尔铜镍合金monkey 渣口小套monoblock casting 块铸monoblock machine 单次拉丝机monochromator 单色光镜monoclinic lattice 单斜晶格monoclinic system 单斜晶系monocrystal 单晶体monocrystal pulling 拉单晶monocrystal substrate 单晶基板monolithic lining 整体炉衬monolithic lining material 整体炉衬材料monolithic refractory 整体耐火材料monopolar system 单极接线法monosilicate 单硅酸盐monosize powder 单粒度粉末monotectic horizontal 偏晶线monotectic line 偏晶线monotectic point 偏晶点monotectic reaction 偏晶反响monotectic transformation 偏晶转变monotectoid reaction 偏析反响monotonous loading 单岛荷monotype metal 单式铸字合金monovariant system 单变系monte carlo simulation 蒙特卡罗模拟mop 挡渣器挡渣杆morphology 形态学mort phase 死相mortar 火泥mosaic block 嵌镶块mosaic structure 嵌镶构造moseley numbers 莫塞莱数mossite 重铌钽矿mossy zinc 粒状锌mother blank 母板mother liquid 母液mother liquor 母液mottled iron 麻口铁mottling 斑点mottramite 矾铜铅矿mountain cork 石棉mouth 炉喉movable armor 可动炉喉护板moving bed process 动态床法moving dislocation 移动位错ms point ms 点muck bar 熟铁粗轧坯mud gun 泥炮muff joint 套管接头muffle furnace 马弗炉muller 碾碎机mullite refractory 莫来石耐火材料multiaxial deformation 多轴变形multiblock machine 屡次拉丝机multiponent solution 多元溶液multiponent system 多元系multicyclone 多管旋风除尘器multidie machine 屡次拉丝机multiflame torch 多线式火嘴multihearth roaster 多层焙烧炉multihole lance 多孔喷枪multilayer welding 多层焊multilayered pipe 多层管multilayered tube 多层管multipass welding 多道焊接multiple drawing 多线式拉拔multiple pressing 复式冲压multiple pressing technique 复式压制工艺multiple process 多段法multiple slip 复滑移multiple spot welding 多点焊multiple stage nitriding 多段渗氮multiplex heat treatment 复合热处理multiplication of dislocation 位错的增殖multiroll flattener 多辊矫直机multiroll mill 多辊式轧机multiroll stand 多辊式机座multiroll straightener 多辊矫直机multirun welding 多道焊接multistage drawing 程序拉拔multistage grate 多层炉multistage process 多段操专multistand mill 多机座轧机multistrand drawing mill 多线拉拔机multistrand rolling 多线轧制multistrand rope 多股钢丝绳multistrand straightening 多条矫直mundic 黄铁矿muntz brass 蒙次黄铜muntz metal 蒙次黄铜muscovite 白云母mushy state 浆糊状态music wire 钢琴丝muthmannite 杂碲金银矿mutual solubility 互溶度。
冶金专业英语词汇（I）
冶金专业英语词汇（I）i bar 工字铁i beam 工字钢i iron 工字铁i steel 工字铁ice point 冰点ideal diameter 理想直径ideal fluid 理想铃ideal gas 理想气体ideal lattice 理想晶格ideal quenching 理想淬火ideal solution 理想溶液idiomorphic crystal 自形结晶idle roll 空转辊ignitability 可燃性igniter 点火器ignition 点火ignition alloy 发火合金ignition furnace 点火炉ignition loss 灼烧损失ignition point 着火点ignition temperature 着火温度ignitron 水银整淋ilmenite 钛铁矿ilmenorutile 黑金红石ilvaite 黑柱石immersed arc 埋弧immersion coating 浸镀immersion plating 浸入电镀immersion test 浸没试验immersion type thermocouple 浸入式热电偶immiscibility 不溶混性immovable bed 固定层impact 冲击impact bend test 冲讳曲试验impact extrusion 冲环压impact load 冲缓载impact resistance 冲昏力impact screen 冲桓impact sintering 冲徽结impact strength 冲豢度impact stress 冲沪力impact test 冲辉验impact test piece 冲辉件impact testing machine 冲辉验机impact toughness 冲煌性impact value 冲坏impeller agitator 桨叶式搅拌机imperfect combustion 不完全燃烧imperfect dislocation 不完全位错imperfection 缺陷impermeability 不渗透性impregnated skeleton 浸渍骨架impression 压痕impulse forming 脉冲成形impulse hardening 冲徊化impulsive load 冲缓载impurity 杂质impurity atom 杂质原子impurity element 杂质元素inactive gas 惰性气体incidental element 杂质元素incipient crack 初裂inclined grate 斜炉栅inclined roll straightening machine 斜辊矫直机inclined throat shears 斜口剪切机inclusion 夹杂物inclusion cleanliness 夹杂物清结度inclusion line 夹杂物线inclusion morphology 夹杂物形态学inclusion stringer 线状夹杂物inclusions floating 夹杂物浮游inclusions source 夹杂物源incoherent boundary 非共格边界incoherent precipitate 非共格沉淀incombustibility 不燃性incomplete annealing 局部退火incomplete austenitizing 部分奥氏体化incomplete combustion 不完全燃烧incomplete fusion 不完全焊透incomplete penetration 不完全焊透incomplete quenching 不完全淬火incompressibility 不可压缩性incompressible fluid 不可压缩铃inconel 因科内尔镍铬铁耐热耐蚀合金incubation period 孕育期incubation time 孕育时间indentation 压痕indentation hardness 压痕硬度indentation method 压痕法independent component 独立组分indianite 埃洛石indicator element 指示元素indicolite 蓝电气石indigolite 蓝电气石indirect analysis 间接分析indirect arc furnace 间接电弧炉indirect reduction 间接还原indirect sintering 间接烧结indirect spot welding 单面点焊indissolubility 不溶性indium 铟indium chloride 氯化铟individual drive 单独传动individual particle 单颗粒individually driven roller 单独传动辊induced draught 吸入通风induction 感应induction brazing 感应钎接induction coil 感应线圈induction furnace 感应炉induction hardening 高频率淬火induction heating 感应加热induction quenching 高频率淬火induction stirring 电磁搅拌induction welding 感应焊接induction welding mill 感应焊管机inductor 感应器industrial alloy 工业合金industrial furnace 工业炉industrial iron 工业铁industrial waste water 工业污水industrial water 工业用水inert arc welding 惰性气体保护电焊inert atmosphere 惰性气氛inert electrode 惰性电极inert gas 惰性气体inertia 惯性inertia moment 惯性矩inertial force 惯性力infection 腐蚀影响infeed accumulator 入口贮料坑infiltrated composite material 溶浸复合材料infiltration 渗透;溶浸infiltration alloy 溶浸合金infiltration by overlay 叠置熔浸infiltration material 熔浸材料infinite fiber 连续纤维inflammability 可燃性inflammation 发火inflection 弯曲inflexion 弯曲inflexion point 回折点infrared pyrometer 红外线高温计infrared radiation 红外线辐射infrared rays 红外线infrared thermometry 红外线测温infusibility 不熔性infusorial earth 硅藻土ingate 浇口ingot 钢锭ingot bleeding 漏钢ingot bogie 送锭车ingot buggy 送锭车ingot butt 钢锭尾部ingot carrier 送锭车ingot casting 铸锭ingot corner segregation 钢锭角偏析ingot dogs 夹锭钳ingot head 钢锭头部ingot mold 锭模ingot pit 均热炉ingot pouring 铸锭ingot pusher 钢锭推出机ingot scalping 钢锭扒皮ingot shell 锭壳ingot stool 底盘ingot stripper 脱模机ingot stripping 脱模ingot structure 钢锭组织ingot tilting device 翻锭机ingot tipper 翻锭机ingot tongs 夹锭钳ingot tumbler 翻锭机ingot turner 钢锭转盘ingot turning device 钢锭转盘ingot yard 钢锭堆场ingotism 师状巨晶ingotting 铸块inherent grain size 固有晶粒度inhibitor 抑制剂;抗氧化剂inhomogeneity 不均质性inhomogeneity of structure 组织不均匀性inhomogeneous system 非均匀系initial creep 初蠕变initial hardness 初始硬度initial permeability 起始磁导率initial section 初始轧断面initial temperature of rolling 初始轧制温度initiation of crack 裂化开始injection 喷射injection burner 喷射烧嘴injection metallurgy 喷吹冶金injection molding 射压造型injection nozzle 喷嘴injector 喷射器inlet guide 进口导板inlet pipe 进气管inlet roll cone 进口辊圆锥inlet valve 进气阀inner cover 内罩inoculant 变质孕育剂inoculant alloy 球化剂合金inoculated cast iron 孕育铸铁inoculation 变质处理inoperative pass 闭口式孔型inorganic salt 无机盐inred process inred 加速还原法insert 垫insert die 插入模inside flash 内焊瘤inside weld 内焊缝insolubility 不溶性insoluble anode 不溶性阳极insoluble residue 不溶残渣insoluble salt 不溶性盐inspection 检查inspection hole 检查孔inspection skid 检查台inspissation 蒸浓instability 不稳定性installation 设备instantaneous cooling rate 瞬时冷却速度instantaneous heating rate 瞬时加热速度instantaneous strain 瞬间应变instrumental analysis 仪浦析instrumental error 仪企差insulating brick 隔热砖insulating layer 绝缘层insulating material 绝缘材料insulating refractory 隔热耐火材料insulation 绝缘insulator 绝缘体intake valve 进气阀integral quantity 积分热力学量integrated iron and steel works 钢铁联合工厂intensity 强度intensive quantity 强度量intensive reduction process inred 加速还原法interaction 相互酌interaction parameter 相互酌参数interannealed wire 中间退火线材interatomic distance 原子间距离interatomic spacing 原子间距离interchangeability 互换性interchangeable converter 可换转炉interchangeable vessel 可换转炉intercommunicating porosity 连通孔隙度intercooler 中间冷却器intercritical annealing 临界区退火intercrystalline brittleness 晶间脆性intercrystalline corrosion 晶间腐蚀intercrystalline crack 晶间裂纹intercrystalline failure 晶间破裂intercrystalline fracture 晶间断裂intercrystalline slip 晶界滑动interdendritic attack 枝晶间腐蚀interdendritic segregation 枝晶间偏析interdiffusion 相互扩散interelectrode distance 电极间距离interface 界面interface reaction 界面反应interfacial energy 界面自由能interfacial friction 边界摩擦interfacial tension 界面张力interfacial zone 界面区interference 干涉interference microscopy 干涉显微方法intergranular corrosion 晶间腐蚀intergranular crack 晶间裂纹intergranular failure 晶间破裂intergranular fracture 晶间断裂;晶间断口intergranular oxidation 晶间氧化intergranular structure 晶间组织intergrowth of crystals 结晶共生interlamellar spacing 层间距intermediate annealing 中间退火intermediate compound 中间化合物intermediate group 中间轧机组intermediate heating 中间加热intermediate layer 中间层intermediate mill 中间轧机intermediate phase 中间相intermediate product 中间产物intermediate reaction 中间反应intermediate roll 中间辊intermediate softening 中间退火intermediate stand 中间机架intermediate table 中间辊道intermediate train 中间轧机组intermetallic compound 金属间化合物intermittent arc 断续电弧intermittent fillet welding 间歇式角焊intermittent seam welding 断续滚焊intermittent weld 间断焊缝intermittent welding 间断焊internal chill 内冷铁internal coat 内部涂覆internal crack 内裂internal defect 内部缺陷internal displacement 内部位移internal energy 内能internal friction 内摩擦internal oxidation 内部氧化internal pressure 内压力internal resistance 内电阻internal strain 内应变internal stress 内应力interparticle spacing 粒子间距interphase 中间相;界面interphase boundary 相间边界interplanar spacing 晶面间距interrupted aging 阶段时效interrupted cooling 断续冷却interrupted quenching 断续淬火interstage annealing 中间退火interstand space 机座间距离interstand tension 机座间张力interstice 晶格原子间隙interstitial 间隙原子interstitial atom 间隙原子interstitial diffusion 间隙扩散interstitial element 间隙元素interstitial impurity 间隙杂质interstitial phase 间隙相interstitial site 间隙位置interstitial solid solution 间隙固溶体interval 区间intracrystalline rupture 穿晶断裂intrinsic energy 内藏能量intrinsic stacking fault 内巽错introduction of dummy bar 引锭杆插入invar 因瓦合金invariant system 不变系inverse annealing 倒逆退火inverse chill 反白口inverse segregation 反偏析inverted extrusion 反挤压investment casting 熔模铸造;熔模铸件investment molding 蜡模造型investment pattern 蜡模iodide 碘化物iodide refining 碘化物精炼iodine 碘ion activity 离子活度ion association 离子缔合ion bombardment 离子轰击ion concentration 离子浓度ion density 离子密度ion exchange 离子交换ion exchange capacity 离子交换能力ion exchange chromatography 离子交换色层法ion exchange column 离子交换柱ion exchange method 离子交换法ion exchange reaction 离子交换反应ion exchange resin 离子交换尸ion exchange separation 离子交换分离ion exchanger 离子交换剂ion implantation 离子注入ion mobility 离子迁移率ion nitriding 离子氮化ion pair 离子偶ion product 离子积ion radius 离子半径ionic bond 离子键ionic compound 离子化合物ionic conduction 离子传导ionic conductivity 离子传导性ionic crystal 离子晶体ionic lattice 离子晶格ionic linkage 离子键ionic migration 离子迁移ionic theory 离子学说ionic valency 离子价ionite membrane 离子交换膜ionization 电离ionization constant 电离常数ionization energy 电离能ionization equilibrium 电离平衡ionization heat 电离热ionization potential 电离势ionization state 电离状态ionization voltage 电离电压ionized atmosphere 离子气氛ionized layer 电离层iridium 铱iridium oxide 氧化铱iridosmine 铱锇合金iron 铁iron and steel industry 黑色冶金iron and steel scrap 废钢铁iron carbide 碳化铁iron carbon alloy 铁碳合金iron carbon diagram 铁碳状态图iron carbonate ore 铁碳酸盐矿石iron constantan thermocouple 铁铜镍热电偶iron foundry 铸适厂iron glance 镜铁矿iron loss 铁氧化损失;铁损iron manufacture 炼铁iron meteorites 铁陨石iron mine 铁矿山iron notch 出铁口iron ore 铁矿石iron ore briquette 铁矿石团块iron ore concentrate 铁精矿iron ore prereduction 铁矿石预还原iron ore sinter 铁矿石烧结矿iron pattern 铁模iron pipe 铁管iron powder 铁粉iron powder electrode 铁粉焊条iron protoxide 氧化亚铁iron runner 龙沟iron rust 铁锈iron sand 铁砂iron shot 铁丸iron wire 铁丝iron yield 铁收得率ironing 展薄拉伸ironmaking 炼铁ironstone 铁矿石ironworks 钢铁冶金工厂irradiation creep 辐照蠕变irradiation damageing 辐照损伤irradiation defect 辐照缺陷irradiation embrittlement 辐照脆化irradiation hardening 辐照硬化irregular powder 不规则状粉irregular section 变截面型材irregularity 不规则性irreversibility 不可逆性irreversible adsorption 不可逆吸着irreversible change 不可逆变化irreversible process 不可逆过程irreversible reaction 不可逆反应irrigated precipitator 湿式电收尘器ishikawaite 铁铌钇矿isobar 等压线isobaric change 等压变化isobaric line 等压线isochoric process 等容过程isochronal annealing 等时退火isolation 隔离isolator 绝缘体isomer 异构体isomerism 异构性isomorphism 同晶型isopotential surface 等位面isostatic mold 等静压模isostatic pressing 等静压制isothermal 等温线isothermal annealing 等温退火isothermal bath 等温浴isothermal change 等温变化isothermal curve 等温线isothermal extrusion 等温挤压isothermal forging 等温锻造isothermal growth 等温生长isothermal hardening 等温淬火isothermal heat treatment 等温热处理isothermal process 等温过程isothermal quenching 等温淬火isothermal section 等温截面isothermal sintering 等温烧结isothermal tempering 等温回火isothermal transformation 等温转变isothermal transformation curve 等温转变曲线isotope 同位素isotopic indicator 同位素指示剂isotopic tracer 同位素指示剂isotropic body 蛤同性体isotropy 蛤同性ixiolite 锰钽矿izod test 艾氏冲辉验。
冶金专业词汇
冶金专业词汇1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering 冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineralresources中国金属学会The Chinese Society for Metals 中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials 矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane 软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass 过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium 相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram 二元相图binary-component phase diagram 三元相图ternary-component phase diagram 液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard 无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation 质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion脱硅desiliconization脱锰demanganization 分配平衡distribution law化学气相沉积chemical vapor deposition(CVD) 4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction 化学控制反应chenical-controlled reaction 混合控制反应mixed-controlled reaction 相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry 熔盐电化学electrochemistry of fused salts 固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor 定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physicalchemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation 中间相成焦机理mesophase mechanism of coke formation选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke 焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine 方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker 尖晶石spinel镁铬尖晶石magnesia chrome spinel，magnesiochromite硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle 定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization石墨纯净化处理purification treatment of graphite 炭砖carbon brick炭块carbon block 碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball 生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running 焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace 休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygenfurnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace 高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM 电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM 等离子连续铸锭plasma progressive casting,PPC 等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF 氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN 瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argonbubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster [连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS。
焊接物理冶金 第一、二章课件
图1-13 焊接参数对温度场分布的影响（10mm厚的低碳钢板） a) q=常数, v的影响;b) v=常数, q及v等比例变化时对温度场的影响
图1-14 在相同的热功率q、热源移动速度v和相同板厚δ条 件下，不同材料板上移动线热源周围的温度场
图1-16 焊接热循环的参数
图1-15 距焊缝不同各点的焊接热循环
表0-2 低碳钢熔敷金属成分及性能变化（同一焊丝）
图0-13 细晶粒低碳钢焊接接头各部位的临界COD值（手弧焊） 1—母材； 2—250℃预热应变的母材； 3—细晶粒的HAZ 4—粗晶粒的HAZ； 5—焊缝（1.58KJ/cm）
焊缝裂纹
火口裂纹
裂纹断裂表面
HAZ裂纹
HAZ裂纹
焊缝气孔
图？ 双椭圆分布热源示意图
图？ 半椭球体分布热源示意图
图？ 双椭球体分布热源示意图
图？ 手工电弧焊原理
第三章 焊缝金属
q 4200W , 0.42W /(cm C ), 0.1cm2 / s
b0 28 10 4 / s, 1cm
图1-9 薄板焊接时的温度场
a) xOy面上平行x轴的温度分布 b) xOy面上的等温线 c) xOy面上平行y轴的温度分布
图1-10 中厚焊件焊接时的温度场
1—焊缝
图0-12 熔焊接头示意 2—熔合区 3—热影响区
图0-2 手工电弧焊接头
图0-13 熔合区
图0-14 熔合线
表0-1 焊接热源能量密度与熔透区截面形状
图0-4 气体保护焊接头
图0-7 电子束焊接头
三、金属的焊接性
1. 焊接冶金问题的提出 （1）焊缝的化学成分、组织及性能与母材有较大的差别； （2）即使焊缝的化学成分与母材相同，但组织和性能不同 （3）HAZ经历了特殊的热循环，组织和性能明显变化； （4）熔合区存在明显的成分、组织及性能的不均匀性； （5）焊接接头易出现裂纹、气孔缺陷。 2. 金属的焊接性的意义 定义：金属焊接性就是金属是否能适应焊接加工而形成完整 的、具备一定使用性能的焊接接头的特性。金属焊接性包括 结合性能（裂纹、气孔、夹渣等）和使用性能（力学性能、 耐蚀性能、耐磨性能等） 两方面。 金属焊接性问题主要来源于焊接冶金特点，从焊接冶金 角度可揭示金属焊接性的本质。
机械类专业课程名称中英文对照.
机械类专业课程名称中英文对照机械制图Mechanical Drawing可编程序控制技术Controlling Technique for Programming金工实习Metal Working Practice毕业实习Graduation Practice理论力学Theoretical Mechanics材料力学Material Mechanics数字电子电路Fundamental Digital Circuit机械控制工程Mechanical Control Engineering可靠性工程Reliability Engineering机械工程测试技术Measurement Techniques of Mechanic Engineering 计算机控制系统Computer Control System机器人技术基础Fundamentals of Robot Techniques最优化技术Techniques of Optimum工程测试与信号处理Engineering Testing & Signal Processing金属工艺及设计Metal Technics ＆ Design机械工业企业管理Mechanic Industrial Enterprise Management机械零件课程设计Course Design of Machinery Elements投资经济学Investment Economics现代企业管理Modern Enterprise Administration市场营销学Market Selling生产实习Production Practice课程设计Course Exercise有限元法FInite Element金工实习Metalworking Practice液压传动Hydraulic Transmission微机原理及接口技术Principle ＆ Interface Technique of Micro—computer 微机原理及接口技术Principle & Interface Technique of Micro-computer 数控技术Digit Control Technique活塞膨胀机Piston Expand er活塞式制冷压缩机Piston Refrigerant Compreessor活塞式压缩机Piston Compressor活塞式压缩机基础设计Basic Design of Piston Compressor活塞压缩机结构强度Structural Intensity of Piston Compressor活赛压机气流脉动Gas Pulsation of Piston Pressor货币银行学Currency Banking基本电路理论Basis Theory of Circuit基础写作Fundamental Course of Composition机床电路Machine Tool Circuit机床电器Machine Tool El ectric Appliance机床电气控制El ectrical Control of Machinery Tools机床动力学Machine Tool Dynamics机床设计Machine Tool design机床数字控制Digital Control of Machine Tool机床液压传动Machinery Tool Hydraulic Transmission机电传动Mechanical ＆ Electrical Transmission机电传动控制Mechanical & electrical Transmission Control机电耦合系统Mechanical & Electrical Combination System机电系统计算机仿真Computer Simulation of Mechanic/El ectrical Systems 机电一体化Mechanical & Electrical Integration机构学Structuring机器人Robot机器人控制技术Robot Control Technol ogy机械产品学Mechanic Products机械产品造型设计Shape Design of Mechanical Products机械工程控制基础Basic Mechanic Engineering Control机械加工自动化Automation in Mechanical Working机械可靠性Mechanical Reliability机械零件Mechanical El ements机械零件设计Course Exercise in Machinery Elements Design机械零件设计基础Basis of Machinery Elements Design机械设计Mechanical Designing机械设计基础Basis of Mechanical Designing机械设计课程设计Course Exercise in Mechanical Design机械设计原理Principle of Mechanical Designing机械式信息传输机构Mechanical Information Transmission Device 机械原理Principle of Mechanics机械原理和机械零件Mechanism ＆ Machinery机械原理及机械设计Mechanical Designing机械原理及应用Mechanical Principle ＆ Mechanical Applications机械原理课程设计Course Exercise of Mechanical Principle机械原理与机械零件Mechanical Principl e and Mechanical Elements 机械原理与机械设计Mechanical Principl e and Mechanical Design 机械噪声控制Control of Mechanical Noise机械制造概论Introduction to Mechanical Manufacture机械制造工艺学Technology of Mechanical Manufacture机械制造基础Fundamental of Mechanical Manufacture机械制造基础(金属工艺学 Fundamental Course of Mechanic Manufacturing （Metal 机械制造系统自动化Automation of Mechanical Manufacture System机械制造中计算机控制Computer Control in Mechanical Manufacture互换性与技术测量El ementary Technol ogy of Exchangeability Measurement焊接方法Welding Method焊接方法及设备Welding Method ＆ Equipment焊接检验Welding Testing焊接结构Welding Structure焊接金相Welding Fractography焊接金相分析Welding Fractography Analysis焊接冶金Welding Metallurgy焊接原理Fundamentals of Welding焊接原理及工艺Fundamentals of Welding ＆ Technology焊接自动化Automation of Welding工程材料的力学性能测试Mechanic Testing of Engineering Materials工程材料及热处理Engineering Material and Heat Treatment工程材料学Engineering Materials工程测量Engineering Surveying工程测试技术Engineering Testing Technique工程测试实验Experiment on Engineering Testing工程测试信息Information of Engineering Testing工程动力学Engineering Dynamics工程概论Introduction to Engineering工程概预算Project Budget工程经济学Engineering Economics工程静力学Engineering Statics工程力学Engineering Mechanics工程热力学Engineering Thermodynamics工程项目评估Engineering Project Evaluation工程优化方法Engineering Optimizational Method工程运动学Engineering Kinematics工程造价管理Engineering Cost Management工程制图Graphing of Engineering电机学Electrical Motor电机学及控制电机El ectrical Machinery Control & Technology。
Welding Metallurgy 焊接冶金
WELDING (WLDG)WLDG 1313.Introduction to Blueprint Reading for Welders. (3-3-0)A study of industrial blueprints. Emphasis placed on terminology, symbols, graphic description, and weldingprocesses. Includes systems of measurement and industry standards. Also includes interpretation of plans anddrawings used by industry to facilitate field application and production. Prerequisite: Bennett MechanicalAptitude Testing score of 42 or above and eligible to enroll in MATH 0306 and READ 0306. F, Sp(4805080000).WLDG 1337.Introduction to Welding Metallurgy. (3-3-0)A study of ferrous and nonferrous metals from the ore to the finished product. Emphasis on metal alloys, heattreating, hard surfacing, welding techniques, forging, foundry processes, and mechanical properties of metalincluding hardness, machinability, and ductility. Prerequisite: Eligible to enroll in MATH 0306 and READ0306. F, Sp (4805080000).WLDG 1412.Introduction to Flux Cored Arc Welding (FCAW). (4-3-3)An overview of terminology, safety procedures, and equipment set-up. Practice in performing T-joints, lapjoints, and butt joints using Flux Cored Arc Welding (FCAW) equipment. Prerequisite or Co-requisite: WLDG1313 and WLDG 1421. Course fee $150. F, Sp (4805080000).WLDG 1421.Welding Fundamentals. (4-3-3) An introduction to the fundamentals of equipment used in oxy-fuel and arc welding, including welding andcutting safety, basic oxy-fuel welding and cutting, basic arc welding processes and basic metallurgy.Prerequisite: Bennett Mechanical Aptitude Testing score of 42 or above and eligible to enroll in MATH 0306and READ 0306. Course fee $150. F, Sp (4805080000).WLDG 1428.Introduction to Shielded Metal Arc Welding (SMAW). (4-3-3)An introduction to shielded metal arc welding process. Emphasis placed on power sources, electrode selection,oxy-fuel cutting, and various joint designs. Instruction provided in SMAW fillet welds in various positions.Prerequisite or Co-requisite: WLDG 1313, WLDG 1421. Course fee $150. F, Sp (4805080002).WLDG 1430.Introduction to Gas Metal Arc Welding (GMAW). (4-3-3)A study of the principles of gas metal arc welding, setup and use of Gas Metal Arc Welding (GMAW)equipment, and safe use of tools/equipment. Instruction in various joint designs. Prerequisite or Co-requisite:WLDG 1313, WLDG 1421. Course fee $150. F, Sp (4805080002).WLDG 1434.Introduction to Gas Tungsten Arc Welding (GTAW) (4-3-3)Principles of gas tungsten arc welding (GTAW), including setup GTAW equipment. Instruction in variouspositions and joint designs. Prerequisite or Co-requisite: WLDG 1313, WLDG 1421. Course fee $150. F, Sp (4805080002).WLDG 1435.Introduction to Pipe Welding. (4-3-3)An introduction to welding of pipe using the shielded metal arc welding process (SMAW), including electrodeselection, equipment setup, and safe shop practices. Emphasis on weld positions 1G and 2G using variouselectrodes. Prerequisite or Co-requisite: WLDG 1313, WLDG 1421. Course fee $150. F, Sp (4805080002).WLDG 1457.Intermediate Shielded Metal Arc Welding (SMAW). (4-3-3)A study of the production of various fillets and groove welds. Preparation of specimens for testing in variouspositions. Prerequisite or Co-requisite: WLDG 1428. Course fee $150. F, Sp (4805080002).WLDG 1491.Special Topics in Welder/Welding Technologist. (4-3-3)Topics address recently identified current events, skills, knowledge, and/or attitudes and behaviors pertinent tothe technology or occupation and relevant to the professional development of the student. This course wasdesigned to be repeated multiple times to improve student proficiency. Prerequisite: WLDG 2443. Course fee$150. F, Sp, Su (4805080002).WLDG 2355.Advanced Welding Metallurgy. (3-3-0) Advanced study of metallurgy as it applies to welding. Includes structure, identification, and testing of metals.Also covers temperature changes and their effect on welded metals, properties of metals, and factors affectingweldability of ferrous and nonferrous metals. Prerequisite: WLDG 1337. F, Sp (4805080000).WLDG 2380.Cooperative Education - Welding Technology/Welder. (3-0-21)Career-related activities encountered in the student's area of specialization offered through an individualizedagreement among the college employer, and student. Under the supervision of the college and the employer, thestudent combines classroom learning with work experience. Includes a lecture component. Prerequisite: WLDG2443. F, Sp, Su I (4805080000).WLDG 2406.Intermediate Pipe Welding. (4-3-3)A comprehensive course on the welding of pipe using the shielded metal arc welding (SMAW) process.Welding will be done using various positions. Topics covered include electrode selection, equipment setup, andsafe shop practices. Prerequisite or Co-requisite: WLDG 1435. Course fee $150. F, Sp (4805080000).WLDG 2432.Welding Automation. (4-3-3) Overview of automated welding and cutting applications. Special emphasis on safe use and operation ofequipment. Prerequisite: WLDG 1428 and WLDG 1430. Course fee $100. F, Sp (4805080000).WLDG 2443.Advanced Shielded Metal Arc Welding (SMAW). (4-3-3)Advanced topics based on accepted welding codes. Training provided with various electrodes in shielded metalarc welding processes with open V-groove joints in all positions. Prerequisite or Co-requisite: WLDG 1457.Course fee $150. F, Sp (4805080000).WLDG 2451.Advanced Gas Tungsten Arc Welding.(GTAW) (4-3-3)Advanced topics in GTAW welding, including welding in various positions and directions. . Prerequisite:WLDG 1435. Prerequisite or Co-requisite: WLDG 1434. Course fee $150. F, Sp, (4805080000).WLDG 2453.Advanced Pipe Welding. (4-3-3) Advanced topics involving welding of pipe using the shielded metal arc welding (SMAW) process. Topicsinclude electrode selection, equipment setup, and safe shop practices. Emphasis on weld positions 5G and 6Gusing various electrodes. Prerequisite or Co-requisites: WLDG 1435 and WLDG 2406. Course fee $150. F, Sp, (4805080000).。
冶金英语词汇(最全)
冶金英语词汇（最全）1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy 系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion 菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physical chemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation中间相成焦机理mesophase mechanism of coke formation 选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite 硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode 石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace 休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH 循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH 真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD 氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM 弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top。
材料成型工艺基础部分(中英文词汇对照)
材料成型工艺基础部分0 绪论金属材料：metal material (MR)高分子材料：high-molecular material 陶瓷材料：ceramic material复合材料：composition material成形工艺：formation technology1 铸造铸造工艺：casting technique铸件：foundry goods （casting）机器零件：machine part毛坯：blank力学性能：mechanical property砂型铸造：sand casting process型砂：foundry sand1.1 铸件成形理论基础合金：alloy铸造性能：casting property工艺性能：processing property 收缩性：constringency偏析性：aliquation氧化性：oxidizability吸气性：inspiratory铸件结构：casting structure使用性能：service performance浇不足：misrun冷隔：cold shut夹渣：cinder inclusion 粘砂：sand fusion缺陷：flaw, defect, falling流动性：flowing power 铸型：cast (foundry mold) 蓄热系数：thermal storage capacity浇注：pouring凝固：freezing收缩性：constringency逐层凝固：layer-by-layer freezing糊状凝固：mushy freezing结晶：crystal缩孔：shrinkage void缩松：shrinkage porosity顺序凝固：progressive solidification冷铁：iron chill补缩：feeding等温线法：constant temperature line method内接圆法：inscribed circle method铸造应力：casting stress变形：deforming裂纹：crack机械应力：mechanical stress热应力：heat stress相变应力：transformation stress气孔：blow hole 铸铁：ingot铸钢：cast steel非铁合金：nonferrous alloy灰铸铁：gray cast-iorn孕育处理：inoculation 球墨铸铁：spheroidal球化处理：sheroidisation可锻铸铁：ductile cast iron石墨：graphite蠕墨铸铁：vermicular cast iron热处理：heat processing熔炼：fusion metallurgy铜合金：copper alloy氢脆：hydrogen brittleness1.2 铸造方法（casting method）手工造型：hand moulding机器造型：machine moulding金属型：metal mold casting金属模：permanent mould压力铸造：press casting熔模铸造：investment moulding蜡膜：cere离心铸造：centrifugal casting低压铸造：casting under low pressure差压铸造：counter-pressure casting陶瓷型铸造：shaw process 1.3 铸造工艺设计浇注位置：pouring position分型面：mould joint活块：loose piece起模：patter drawing型芯：core型芯撑：chaplet工艺参数：processing parameter下芯：core setting合型：mould assembly冒口：casting head 尺寸公差：dimensional tolerance尺寸公差带：tolerance zone机械加工余量：machining allowance铸孔：core hole非标准：nonstandard label 收缩率：rate of contraction线收缩：linear contraction体收缩：volume contraction起模斜度：pattern draft铸造圆角：curvingof castings芯头：core register芯头间隙：clearance芯座：core print seat 分型线：joint line分模线：die parting line1.4 铸造结构工艺性加强筋：rib reinforcement撒砂：stuccoing内腔：entocoele2 金属塑性加工塑性加工：plastic working塑性：plastic property锻造：forge work冲压：punching轧制：rolling拉拔：drawing挤压：extruding细化晶粒：grain refinement热锻：hit-forging温锻：warm forging 2.1 金属塑性加工理论基础塑性变形：plastic yield加工硬化：work-hardening韧性：ductility回复温度：return temperature再结晶：recrystallize再结晶退火：full annealing冷变形：cold deformation热变性：heat denaturation锻造比：forging ratio镦粗：upset拔长：pull out纤维组织：fibrous tissue 锻造性能：forging property可锻性：forgeability变形抗力：resistance of deformation化学成分：chemical constitution热脆性：hot brittleness 冷脆性：cold-shortness变形速度：deformation velocity应力状态：stress condition变形温度：deformation temperature过热：overheating过烧：burning脱碳：carbon elimination始锻温度：initiation forging temperature终锻温度：final forging temperature2.2 金属塑性加工方法自由锻：flat-die hammer冲孔：jetting弯曲：bend弯曲半径：bending radius切割：cut扭转：twist rotation错移：offsetting锻接：percussion基本工序：basic process辅助工序：auxiliary process精整工序：finishing process模锻：contour forging锻模：forging die 胎膜锻：fetal membrane forging剪床：shearing machine冲床：backing-out punch冲裁：blanking弹性变形：elastic distortion塑性变形：plastic yield剪切变形：shearing deformation最小弯曲半径：minimum bending radius曲率：angularity弯裂：rupture 回弹：rebound辊轧：roll forming辊锻：roll forging斜轧：oblique rolling 横轧：transverse rolling辗压：tamping drum挤压：extruding拉拔：draft2.3 塑性加工工艺设计工艺规程：process specification锻件图：forging drawing敷料：dressing锻件余量：forging allowance锻件公差：forging tolerance 工夹具：clamping apparatus加热设备：firing equipment加热规范：heating schedule冷却规范：cooling schedule后续处理：after treatment分模面：die parting face冲孔连皮：punching the wad模锻斜度：draft angle圆角半径：radius of corner圆饼类锻件：circumcresent cake-like forging长轴类锻件：long axis-like forging2.4 锻件结构工艺性锥体：cone斜面：cant空间曲线：curve in space粗糙度：degree of roughness2.5 冲压件结构工艺性3 焊接焊接：welding铆接：riverting熔焊：fusion welding压焊：press welding 钎焊：braze welding3.1 焊接理论基础冶金：metallurgy电弧焊：arc welding气焊：acetylene welding电渣焊：electro-slag welding高能束焊：high energy welding电子焊：electronic welding激光焊：laser welding等离子焊：plasma welding 电弧：electric arc阳极区：anode region阴极区：negative polarity弧柱区：arc stream正接法：electrode negative method反接法：opposition method脱氧剂：deoxidizing agent焊缝：welded seam 焊缝区：weld zone熔合区：fusion area热影响区：heat-affected zone 脆性断裂：brittle fracture过热区：overheated zone正火区：normalized zone相变区：phase change zone焊接应力：welding stress收缩变形：contraction distortion角变形：angular deformation弯曲变形：bend deformation扭曲变形：warping deformation波浪变形：wave transformation反变形法：reversible deformation method刚性固定法：rigid fixing method预热：warming-up缓冷：slow cool焊后热处理：postweld heat treatment 矫形处理：shape-righting3.2 焊接方法埋弧焊：hidden arc welding气体保护焊：gas shielded arc welding氩弧焊：argon welding熔化极氩弧焊：consumable electrode argon welding钨极氩弧焊：argon tungsten-arc welding二氧化碳气体保护焊：CO2 gas shielded arc welding碳弧焊：carbon arc welding碳弧气刨：carbon arc air gouging电渣焊：electro-slag welding 高能焊：high grade energy welding等离子弧切割：plasma arc cutting (PAC)堆焊：bead weld电阻焊：resistance welding电焊：electric welding缝焊：seam welding压焊：press welding多点凸焊：multiple projection welding对焊：welding neck摩擦焊：friction welding扩散焊：diffusion welding硬钎料：brazing alloy软钎料：soft solder3.3 常用金属材料的焊接焊接性：weldability焊接方法：welding method焊接材料：welding material焊条：electrode焊剂：flux material碳素钢：carbon steel低碳钢：low carbon steel中碳钢：medium carbon steel高碳钢：high carbon steel低合金钢：lean alloy steel不锈钢：non-corrosive steel有色金属：nonferrous metal3.4 焊接工艺设计型材：sectional bar药皮：coating焊丝：soldering wire连续焊缝：continuous weld断续焊缝：intermittent weld应力集中：stress concentration焊接接头：soldered joint坡口：groove对接：abutting joint搭接：lap joint角接：corner joint 4 粉末冶金（power metallurgy）粉末冶金成品：finished power metallurgical product铁氧体：ferrite硬质合金：sintered-carbide高熔点金属：high-melting metal陶瓷：ceramic4.1 粉末冶金工艺理论基础压坯：pressed compact扩散：diffusion烧结：agglomeration固溶：solid solubility化合：combination4.2 粉末冶金的工艺流程制备：preparation预处理：anticipation还原法：reduction method电解法：electrolytic method雾化法：atomization松装密度：loose density 流动性：flowing power压缩性：compressibility筛分：screen separation 混合：compounding制粒：pelletization过烧：superburning欠烧：underburnt5 金属复合成型技术自蔓延焊接：SHS welding热等静压：HIP准热等静压：PHIP5.1 液态成型技术与固态成型技术的复合高压铸造：high-pressure casting电磁泵：magnetic-pump压射成型：injection molding柱塞：plunger piston冲头：drift pin凝固法：freezing method挤压法：extrusion method转向节：knuckle pivot制动器：arresting gear5.2 金属半凝固、半熔融成型技术凝固：freezing半熔融：semi-vitreous触变铸造：thixotropy casting触变锻造：thixotropy forging注射成型：injection molding5.3 其他金属成型新技术快速凝固：flash set非晶态：amorphous溢流法：press over system喷射沉积：ejecting deposit爆炸复合法：explosion cladding method扩散焊接：diffusion welding挤压：extruding轧制：roll down6 非金属材料成型技术6.1 高分子材料成型技术高分子材料：non-metal material耐腐蚀：resistant material绝缘：insulation老化：ageing耐热性：heat-durability粘弹性：viscoelasticity塑料：plastic material橡胶：rubber合成纤维：synthetic fibre涂料：covering material粘结剂：agglomerant 粘度：viscosity热塑性塑料：thermoplastic plastics热固性塑料：thermosetting plastic通用塑料：general-purpose plastics 工程塑料：engineering plastic薄膜：thin film增强塑料：reinforced plastics浇注塑料：pouring plastics注射塑料：injiection plastics挤出塑料：extrusion plastics吹塑塑料：blowing plastics模压塑料：die pressing plastics聚合物：ploymer semiconductor吸湿性：hygroscopic cargo定向作用：directional action生胶：green glue stock填料：carrier丁苯橡胶：SBR顺丁橡胶：BR 氯丁橡胶：CR丁腈橡胶：NBR硅橡胶：Q聚氨酯橡胶：U压延：calender硫化：sulfuration胶粘剂：adhesive胶接：glue joint刹车片：brake block零件修复：parts renewal蜂窝夹层：honeycomb core material6.2 工业陶瓷制品的成型技术干燥：drying坯料：blank润滑剂：anti-friction结合剂：binder热压铸：hot injiection moulding6.3 非金属材料成型技术的新进展热压烧结：hot pressed sintering7 复合材料的成型技术复合材料：composite material树脂：resin7.1 金属复合材料的成型技术硼纤维：boron fiber钛合金：titanium alloy碳纤维：carbon filter等离子喷涂：plasma spraying浸渍法：immersion method锭坯：ingot blank7.2 聚合物基复合材料的成型技术晶须：whisker缠绕成形：enwind forming湿法缠绕：wet method enwind 7.3 陶瓷复合材料成型技术料浆：slurry溶胶-凝胶法：sol-gel method化学气相沉积：chemical vapor deposition (CVD)原位：in situ8 材料成型方法的选择粉末冶金：powder metallurgy工程塑料：engineering plastics工程陶瓷：engineering ceramics。
冶金专业英语词汇整理
专业英语词汇1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing 矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine 露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing 对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy 系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram 二元相图binary-component phase diagram 三元相图ternary-component phase diagram 液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent 固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model 扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physical chemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金 5.1 炼焦炼焦coking高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation中间相成焦机理mesophase mechanism of coke formation 选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke 针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite 硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory 半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle 定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler 环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace休风率delay ratio高炉寿命blast furnace campaign悬料hanging 崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch 风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling 热风炉hot blast stove燃烧室combustion chamber 燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve 旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process直接炼钢法direct steelmaking process 混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation 还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials 添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance 钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere 挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation 白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH 真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting 坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM 弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice 多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS 浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top钢锭缩头piped top表面缺陷surface defect内部缺陷internal defect缩孔shrinkage cavity中心缩孔center line shrinkage气孔blowhole表面气孔surface blowhole皮下气孔subskin blowhole针孔pinhole铸疤feather冷隔cold shut炼钢缺陷lamination发裂flake,hair crack纵裂longitudinal crack横裂transverse crack角部横向裂纹transverse corner crack 角部纵向裂纹longitudinal corner crack 收缩裂纹shrinkage crack热裂hot crack冷裂cold crack冷脆cold shortness热脆hot shortness夹渣slag inclusion皮下夹杂subsurface inclusion正偏析positive segregation 负偏析negative segregation,inverse seregation V形偏析∨-shaped segregation倒V形偏析∧-shaped segregation中心偏析center segregation中心疏松center porosity鼓肚bulging脱方rhomboidity连铸-直接轧制continuous casting-direct rolling 工艺CC-DR6 钢铁材料铸铁cast iron熟铁wrought iron电解铁electrolytic iron白口铸铁white cast iron灰口铸铁grey cast iron麻口铸铁mottled cast iron变性铸铁modified cast iron孕育铸铁inoculated cast iron冷硬铸铁chilled cast iron球墨铸铁nodular cast iron蠕墨铸铁vermicular cast iron可锻铸铁malleable cast iron半可锻铸铁semi-malleable cast iron奥氏体铸铁austenitic cast iron贝氏体铸铁bainitic cast iron共晶白口铁eutectic white iron亚共晶白口铁hypoeutectic white iron过共晶白口铁hypereutectic white iron结构钢constructional steel软钢mild steel普通碳素钢plain carbon steel正火钢normalized steel热轧钢hot rolled steel高强度低合金钢high-strength low-alloy steel 微合金钢micro-alloy steel冷轧钢cold rolled steel深冲钢deep drawing steel双相钢dual phase steel渗碳钢carburizing steel渗氮钢nitriding steel调质钢quenched and tempered steel超高强度钢ultra-high strength steel不锈钢stainless steel奥氏体不锈钢austenitic stainless steel铁素体不锈钢ferritic stainless steel马氏体不锈钢martensitic stainless steel双相不锈钢duplex stainless steel马氏体时效钢maraging steel耐蚀钢corrosion-resisting steel耐热钢heat-resisting steel弹簧钢spring steel。
矿业专用英语(中英文对照)
1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing 矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity 矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period 矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources 矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite 铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing 粗碎primary crushing中碎secondary crushing 细碎fine crushing对辊破碎机roll crusher 粉磨机pulverizer震动筛vibrating screen 筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizerabandoned drives [ə'bændənd] [draivs] 废巷道abrasion resistance [ə'breiʒən] [ri'zistəns] 抗磨蚀能力abrasive [ə'breisiv] 磨料absorbent [əb'sɔ:bənt] 吸收剂access ramp ['ækses] [ræmp] 出入沟，出入引道accessory minerals [ək'sesəri] ['minərəls] 副矿物accidental explosion [,æksi'dentəl] [ik'spləuʒən] 意外爆炸Accumulated losses 累计亏损Acid Mine Drainage 矿山酸性废水Acidic run-off water from mine waste dumps and mill tailings ponds containing sulphide minerals. Also refers to ground water pumped to surface from mines.acid mine water ['æsid] [main] ['wɔ:tə] 酸性矿水acid resistant ['æsid] [ri'zistənt] 耐酸的acid rock ['æsid] [rɔk] 酸性岩acidite ['æsidait] 酸性岩acidulation 酸化acquirer投资主体Acquisition premium 收购溢价activated charcoal ['æktiveitid] ['tʃɑ:kəul] 活性煤activator ['æktiveitə] 活化剂adamic earth ['ædəmik] [ə:θ] 红粘土additive ['æditiv] 添加剂adhere [əd'hiə] 粘着adhesion force [əd'hi:ʒən] [fɔ:s] 粘附力Adit ['ædit] 平硐An opening driven horizontally into the side of a mountain or hill for providing access to a mineral deposit.adit collar ['ædit] ['kɔlə] 平硐口adit cut mining ['ædit] [kʌt] ['mainiŋ] 平硐开采adjustable prop [ə'dʒʌstəbl] [prɔp] 伸缩式支柱Administration and Corporate expenses行政管理及公司费用Administrative expenses 管理费用adobe blasting [ə'dəubi] ['blɑ:stiŋ] 裸露装药爆破adobe shot [ə'dəubi] [ʃɔt] 裸露装药爆破advancement [əd'vɑ:nsmənt, əd'væns-] 掘进。
冶金专业英语词汇整理
..专业英语词汇1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing 矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel 有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity 矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite................... tuyere cooler风口水套tuyere stock风口弯头tuyere风口twin-belt caster双带式连铸机twin-hearth furnace双床平炉two-bells system charging双料钟式装料type steel轮箍钢ultimate analysis of coke 焦炭元素分析ultrafine particle超微颗粒ultra-high power electric arc furnace超高功率电弧炉ultra-high power graphite electrode超高功率石墨电极ultra-high strength steel超高强度钢ultrasonic particle sizer, supersonic particle sizer超声粒度计under blowing 慢风underground mine地下矿山underground mining地下采矿undersize筛下料unreacted core model未反应核模型upper cone炉帽utilization coefficient利用系数vacuum arc degassing, VAD真空电弧脱气vacuum arc remelting, VAR真空电弧炉重熔vacuum casting真空浇铸vacuum decarburization真空脱碳vacuum degassing furnace, VDF真空脱气炉vacuum degassing真空脱气vacuum induction melting, VIM真空感应炉熔炼vacuum Kimitsu injection process君津真空喷粉法vacuum metallurgy真空冶金(学)vacuum oxygen decarburization process ,VOD真空吹氧脱碳法vacuum refining真空精炼valuable mineral有用矿物vanadium titano-magne钒钛磁铁矿titevaporization cooling汽化冷却vein矿脉vermicular cast iron蠕墨铸铁vermiculite蛭石vermiculizer蠕化剂vertical caster立式连铸机vertical guide roll立式导辊vertical-bending caster立弯式连铸机vibrating screen震动筛viscosity粘度weir and dam in tundish中间包挡墙welding metallurgy焊接冶金(学)wetting润湿white cast iron白口铸铁white slag白渣withdrawal roll拉辊wollastonite硅灰石working bolume工作容积wrought iron熟铁wustite维式体xylene二甲苯yield产率zero order reaction零级反应zirconia graphite brick锆炭砖zoned lining分区砌砖.。
焊接冶金与金属焊接性
（1）增加了熔滴相的接触面积 （2）有利于反应物和产物进入和退出反应表面
——加快反应速度。
第一章 焊接化学冶金
总之：
熔滴反应时间短，温度高，相接触面积大， 有强烈的混合作用——反应最激烈，许多冶金反 应可以达到接近终了的程度——对焊缝成分影响 最大。
熔滴主要反应：气体的溶解和分解，金属的蒸 发，金属及其合金成分的氧化和还原，焊缝金属 的合金化等。
第一章 焊接化学冶金
三、焊接化学冶金反应区及其反应条件
分区域（阶段）连续进行： 焊条——熔滴——熔池
第一章 焊接化学冶金
第一章 焊接化学冶金
（一）药皮反应区
温度100oC → 焊条熔化温度（钢焊条1500oC
） 主要反应：脱水、造气
吸附水蒸发，结晶水排除，白泥、白云母中的结晶水 ，温度与成分有关。
焊接时，电流通过焊芯时产生电阻热，从而使焊 条的温度升高，同时，电弧产生的热量使焊条熔化。
第一章 焊接化学冶金
2、焊接金属熔滴及其过渡特性 焊条端部熔化形成的滴状液态金属称为熔滴
焊接过程 稳定性
重点研究
熔滴特性 至关重要
焊接冶金
焊缝成形
熔滴过渡的分类
MAG焊的熔滴过渡形式
Rotary arc
Pulsed arc Short arc
过渡速度高达2.5～10m/s。 经过弧柱区的时间极短，只有0.0001～0.001s。 各相接触时间平均为0.01～0.1s。
反应主要在焊条末端进行。反应进行很剧烈。
第一章 焊接化学冶金
4、与熔渣发生强烈混合 熔滴的形成、长大过程中，表面形状不断变化，
表面不断破坏，表面渣层破坏，渣与熔滴交流。熔 滴中有渣，渣被熔滴金属包围。
采矿专业英语
bed, deposit, field 书馆矿床outcrop 露头fault 断层vein, sean, lode 矿脉gold reef 金矿矿脉pocket 矿穴reservoir 储藏water table 潜水面，地下水面mine 矿stratum, layer 矿层quarry 露天采石clay pit 粘土矿坑peat bog 泥炭沼gold nugget 块金gangue 脉石，矿石，尾矿prospector 探矿者prospecting 探矿boring, drilling 钻探auger, drill 钻excavation 发掘quarrying, extraction 采石borer, drill, drilling machine 钻机stonemason 石工锤stonecutter 切石机miner 矿工mining engineer 采矿工程师pan 淘金盘氨基三乙酸(NTA) || aminotriacetic acid 胺基 || amino铵基 || ammonium安全地层 || safe formation安全试破 || safe destruction安全钻井 || safe drilling坳陷 || down warping region螯合 || chelation凹陷 || sag凹陷地层 || subsidence formation奥陶系 || Ordovician systemAPI模拟法 || API recommened methodB多靶点 || multiple target point白沥青 || white asphalt白油 || mineral oil白云母 || white mica半透膜 || semipermeable membrane包被絮凝剂 || flocculant包被 || envelop包被抑制性 || encapsulating ability 饱和度 || saturation饱和度剖面图 || profile map of degree of saturation饱和盐水 || saturated salt water背斜 || anticlinal钡 || barium苯环 || benzene ring苯酚 || phenyl hydroxide本质区别 || essential difference泵压过高 || overhigh pumping pressure 比表面积 || specific surface area比吸水量 || specific absorption比重瓶法 || density bottle method避免 || avoid蓖麻油 || ricinus oil边界摩擦 || boundary friction扁藻（浮游植物） || algae变化趋势 || variation trend标准化 || standardization标准粘度测量 || standard visicosity measure表面粗糙度 || roughness of the surface 表面电位 || surface electric potential 表面活性剂 || surfactant ,surface active agent表面能 || interface energy表面粘度 || surface viscosity表面抛光 || sample surfaceAibbs表面弹性 || Aibbs surface elasticity表面张力 || surface tension表明 || verify /reveal表皮系数(S) || skin coefficient憋钻 || bit bouncing宾汉方程 || bingham equation丙三醇 || glycerine丙烯情 || acrylonitrile丙烯酸 || acrylic acid丙烯酸盐 || acrylate丙烯酰胺 || acrylamide薄而韧的泥饼 || thin,plastic and compacted mud-cake ||薄片 || flake薄弱地层 || weak formation泊松比|| poisson’s ratio剥离 || peel off补救 || remediation不分散泥浆 || nondispersed mud不干扰地质录井 || play no role in geological logging不均质储层 || heterogeneous reservoir 不均匀 || uneven不可逆 || irreversible不同程度 || inordinately部分水解聚丙烯酰胺(PHPA) || partially hydrolyzed polyacrylamideC参数优选 || parametric optimization 残酸 || reacted acid残余饱和度 || residual staturation残渣 || gel residue , solid residue测量 || measure侧链 || side chain侧钻水平井 || sidetrack horizontal well 层间 || interlayer层间距 || the distance between the two crystal layer, layer distance层理 || bedding层流 || layer flow差减法 || minusing尝试 || trial柴油 || diesel oil长连缔合物 || long chain associated matter操作方法 || operation method超伸井 || high deep well超深预探井 || ultradeep prospecting well超声波 || ultrasonography超高密度泥浆 || extremely high density mud超细碳酸钙 || super-fine calcium carbonate产层 || production/pay zone产层亏空 || reservoir voidage产量 || production ,output沉淀 || precipitation沉降 || subside沉降速度 || settling rate沉砂 || sand setting衬套 || sleeve程序 || program采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, sur face mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy 化学冶金（学）chemical metallurgy 物理冶金（学）physical metallurgy 金属学Metallkunde冶金过程物理化学physical chemistry of process metallu rgy冶金反应工程学metallurgical reaction engineering 冶金工程metallurgical engineering 钢铁冶金（学）ferrous metallurgy, metallurgy of iro n and steel有色冶金(学)nonferrous metallurgy 真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy 喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy 焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilizat ion of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of Chin a采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials 矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining 矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration 矿山可行性研究mine feasibility study 矿山规模mine capacity矿山生产能力mine production capacity 矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period 矿山达产arrival at mine full capacity 开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources 矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics选矿选矿厂concentrator, mineral processing plant工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentra tion磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing 自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite 铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing 粗碎primary crushing 中碎secondary crushing 细碎fine crushing对辊破碎机roll crusher 粉磨机pulverizer震动筛vibrating screen 筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer 超声粒度计ultrasonic particle sizer, supersonic particle sizer。
冶金专业英语词汇(简版)
冶金专业英语词汇21 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineralresources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output 矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution 破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher 粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizeriron and steel industry 钢铁工业ironworks铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy电冶金学powder metallurgy粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口，出渣口pig bed 铸床mould 铸模（美作：mold）tuyere, nozzle 风口ingot mould 锭模（美作：ingot mold）floor 平台hearth 炉底charger装料机ladle 铁水包，钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉，冲天炉emptier 排空装置trough 铁水沟，排渣沟skip 料车rolling mill 轧机，轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing轧机机架drawbench 拔管机，拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining耐火砖衬retort 反应罐muffle 马弗炉roof, arch炉顶forge 锻造press 压锻pile hammer打桩锤drop hammer 落锤die拉模blowlamp 吹炬（美作：blowtorch）crusher 破碎机iron ore 铁矿石coke 焦炭bauxite铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿（美作：hematite）gangue 脉石cast iron铸铁cast iron ingot铸铁锭slag 炉渣soft iron软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢，低碳钢hard steel 硬钢cast steel 坩埚钢，铸钢stainless steel 不锈钢electric steel 电工钢，电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢，耐热钢alloy steel 合金钢plate, sheet薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品，产品semifinished product 半成品，中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带，钢带billet 坯锭，钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体，铁醇盐cementite 渗碳体，碳化铁pearlite 珠光体charging, loading 装料，炉料fusion, melting, smelting 熔炼remelting 再熔化，重熔refining 精炼casting 出铁to cast 出铁tapping 出渣，出钢，出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火annealing 退火reduction 还原cooling 冷却decarbonization, decarburization脱碳coking 炼焦slagging, scorification造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化，雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型（美作：molding）calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔。